Subaru Robin Power Products RGX405, RGX405D manual Fuel Tank

Page 60

10-3-8 FUEL TANK

1)Attach the strainer, nut, and banjo to the strainer bracket.

2)Remove the front panel from the control box, and mount the strainer bracket.

5q5~12mmbolt...2pcs. Mount the front panel again.

3)Mount the fuel tank on the side plates with rubber washers between the side plates and the fuel tank. 84x 18mmbolt...4pcs.

4)Connect the rubber pipes.

First, fit the hose clamps on the rubber pipe, connect the strainer and fuel tank, fasten the rubber pipe with the hose clamps.

NOTE: Keep the strainer in the off position until the pipe has been connected. (See F&. 10-33.)

FUEL GAUGE

/FUEL

TANK

RUBBER	PIPE 1 .	II	I	HOSE CLAMPS
\-----			I-	HOSE CLAMPS
\-----
	STRAINER	u	I
		u	I

gK,q\

‘RUBBER

PIPE 2

CONTROL

BOX

‘FUEL

STRAINER

Fig. lo-33

- 57 -

Image 60

Contents Generator Page Contents For U.S.A. and Canadian markets Type12V 5OHZ Power Factor Type SelfEY25-2D EY25W VoltageW210 Model Voltage 11 OVl22OVAra similar to 6OHz I lOVR2OV, 5OHz 12OVR4OV RGX505 Type EY40DWl-3905000 MainSak,l~rl?rv%!-kUT-I EY40D Wl-390Features Page Ii z 3, G Am 4 si Panel a RGX305 22ov, 23ov RGX405 22ov, 23ovRGX505 22OV 23OV RGX305 llOV, 12Ov RGX405 llOV RGX505 llOVPanel B RGX305 RGX405 RGX505RGX305D RGX405D Through Bolt Slip Ring Cover Boltfront Covershaft +yg+++j FunctionsStator Inch Rotor99.6 Inch Bnml 100Brushes AVR Automatic Voltage RegulatorVoltmeter Have their Rated capacities. Refer to 5-2-8 ReceptaclesBreaker PlugFuse capacity 1OA FuseReceptacle and AC Plugs Tz&@L 1 Rear Cover Rubber Mounts Rubber Vibration IsolatorsPipe Frame Revolving FieldRevolving Armature Type Page Primary Exciting Action Voltage Regulating MechanismCircuit diagram of the conventional dual voltage type is Shown in 18, and a circuit diagram of the RGXFull Power Switch SwitchChange of Engine Parts Ignition SystemControl System FUEL’SYSTEM CRANKCASE-l/SEALWASHER Cooling SystemSwitch 15A Switch 30ASwitch 60A Switch 15A 34845609When Starting their mOtOfs Once Are started, the products Consume only aboutAbout 5OHZ 6OHZ1OOOW Nominal Cross Frequency range About 45 to 65 Hz Meters 1 Voltmeters2 Ammeters 3 Frequency MeterUsed for measuring resistance, etc TesterMegger Tester TachometerAC Output Measuring Rated Voltage 11ov 12OV 220 230vRange 108-115V 118%125V 218 225 228 235 238 245 DC Output MeasuringStator RotorControl BOX Stator Assembly Wire color 1 Blue BLUE0.2L Measuring Winding Resistance 60Hz 11 OV, 12OV QVi22QV, 12OVl24OVResistance Rotor Assembly Wwding Resistance Measuring Cleaning Slip RingsRefer to 8-4 Measuring Insulation Refer to 8-4 Measuring Insulation ResistanceBrushes AVR Trouble Identification by AppearanceIdentifying AVR Trouble by Checking INTER-LEAD Resistance1OKR 250K-3OOKSZOS2 3OOKROnly the LG301 and LG301D have a no-fuse breaker Fuse Holder and NO-FUSE HolderNO-FUSE Breaker Fuse HolderDiode Stack Assembly Receptacle and AC PlugVoltmeters Terminals ‘-IPrimary Exciting Circuit Exciting CoilBe careful not to pinch the wiring Fuel Tank Remove the frontFuel pipe Remove the fuel tank boltsControl Box That are connect to the rearRemarksTool Frame It is not necessary to reMove the air guide Generator. See O-7Brush holder Remove the brush cover Rear cover Screw pcs Remove the brush holders See FigBrushes before removing the brush HoldersStator Remove the stator Sever hammer the windIngs and leads By lightly tapping the outsideRotor Fit a box Hammer Spanner or socket wrench overStrike it Shaft BoltFig. lo-16 Order HOW to Reassemble Front CoverInch RGX505 10mm 260 mmFig. lo-19 Fig. lo-20Tighten the cover bolt RGX305 Lo-25 Brush HolderInstall the brush cover. RGX305, RGX305D FrameFig. lo-32 Fig. lo-30Fuel Tank 5q5~12mmbolt...2pcs. Mount the front panel againReverse the disassembly procedure DisassemblyFirst, and then remove them TROUBLE-SHOOTING CausePage Voltage too low Kau!w RemedyPage Electric Starter LEXCITING Coil12-l-2 Speed Control Bracket RGX305,305D Control BOX on Engine Side12-l -4 Strainer Bracket 12-6 Standard Electric StartCaster Generator BOX Engine~~ ~~ Control BOX EngineRGX305 I IOV-I 2OVl RGX405 IlO-12OV RGX505D ~m&,v,240vGEN&ATOR Control BOX Engine SIUIssue EMD-GS0005