American Dryer Corp AD-235D

ADC 113118 1- 11/11/99-50 2- 11/29/99-200 3- 01/03/00-500

4- 08/04/00-500 5* 09/11/00-25

Contents

Main AD-235D/AD-235ED Installation Manual Retain This Manual In A Safe Place For Future Reference Important Page Page Table of Contents Page SECTION I IMPORTANT INFORMATION A. RECEIVING and HANDLING B. SAFETY PRECAUTIONS Page Gas SECTION II SPECIFICATIONS A. SPECIFICATIONS Page Page SECTION III INSTALLATION PROCEDURES IMPORTANT: The dryer must be installed on noncombustible floors only. A. UNPACKING/SETTING UP B. LOCATION OF THE DRYER IMPORTANT: Dryer should be located where a minimum amount of exhaust duct will be necessary. C. DRYER ENCLOSURE REQUIREMENTS D. FRESH AIR SUPPLY Page E. EXHAUST REQUIREMENTS Page Page Page F. ELECTRICAL INFORMATION IMPORTANT: For personal safety and proper operation, the dryer must be grounded. S L C E ) ADG-230D (Gas) ADG-235ED (Gas) PER DRYER ( PECIFICATIONS S G. GAS INFORMATION T G G T 14.92 - 29.9 mb Page Page H. PREPARATION FOR OPERATION I. PREOPERATIONAL TESTS Page J. SHUT DOWN INSTRUCTIONS SECTION IV OPERATING INSTRUCTIONS A. STARTING THE DRYER Page SECTION V SERVICE/PARTS INFORMATION A. SERVICE B. PARTS SECTION VI WARRANTY INFORMATION A. RETURNING WARRANTY CARD(S) B. WARRANTY C. RETURNING WARRANTY PART(S) Page SECTION VII ROUTINE MAINTENANCE A. CLEANING Page B. ADJUSTMENTS C. LUBRICATION SECTION VIII TROUBLESHOOTING Page G. Microprocessor controller (computer) light emitting diode (L.E.D.) display reads Hot... H. Microprocessor controller (computer) L.E.D. display reads SEFL... Possible causes: Page N. No heat... ignitor sparks but there is no flame at burner... O. No heat... ignitor sparks, burner goes on and off right away... P. Dryer operates, but is taking too long to dry... Q. Condensation on main door glass... R. Dryer is making scraping noise at basket (tumbler) wrapper area... S. Excessive noise and/or vibration... Page Page SECTION X Page Page SECTION XI BURNER/TUMBLER HI-LIMIT MANUAL RESET INSTRUCTIONS IMPORTANT