Pressure Washer

Maintenance

Observe regular maintenance intervals to ensure maximum performance and life from the pressure washer.. Refer to the schedule for recommended maintenance.. If you operate the pressure washer in dusty conditions, perform maintenance checks more often..

engine Oil changing instructions

Drain the engine oil when th engine is warm.. Warm oil drains quickly and completely..

1..Turn the fuel valve to the OFF position to reduce the possibility of fuel leakage..

2..Place a suitable container next to the engine to catch the used oil..

3..Remove the oil filler cap/dipstick and drain the oil into the container by tipping the engine toward the oil filler neck..

Please dispose of used motor oil in a manner that is compatible with the envirionment.. We suggest you take used oil in a sealed container to your local recycling center or service station for reclamation .. Do not throw into the trash, oust it on the ground, or pour it down a drain..

4..With the engine in a level postion, fill to the upper limit mark on the dipstick with the recommended oil..

running the engine with a low oil level can cause engine damage.

Oil filler neck

Oil filler cap/

 

 

dipstick

Upper limit

Figure 12 – Oil Drain Location

pump Oil changing instructions

Changing or refilling the oil in the pump requires removal of the pump from the engine and should not be required unless oil has leaked out due to worn or damaged oil seals in the pump.. If oil has leaked out of the pump, bring the pressure washer to a certified Campbell Hausfeld service center for repair..

5.. Reinstall the oil filler cap/dipstick securely..

Maintenance Schedule

Maintenance Schedule

Action Needed

Daily

• Check water inlet screen and

 

 

filter..

 

•

Check engine oil levels. Fill as

 

 

necessary..

 

•

Check gasoline level. Fill as

 

 

necessary..

 

 

After first 5 hours of

• Change engine break-in

operation

 

oil.. Use SAE30 or 10W-30

 

 

detergent oil..

 

 

Every 25 hours of

• Change oil if operating under

operation

 

heavy load or high ambient

 

 

temperature..

 

•

Clean or replace paper air

 

 

cleaner cartridge.. Tap gently

 

 

to remove dirt..

 

 

 

Every 50 hours of

•

Change oil.

operation

 

 

 

•

Replace spark plug.

 

 

 

Each 100 hours of

•

Replace paper air cleaner

operation or every 3

 

cartridge..

months

• Change engine oil.

Technical and Consumer Information

Vertical Oriented Pressure Washers

Engine Oil Type

SAE 10W-30

 

SAE 30W (Above 60° F)

 

 

Engine Oil Capacity

 

Honda Engines

18..5 fl.. oz..

 

 

Engine Fuel Capacity

 

Honda Engines

0..29 gal

 

 

Pump Oil Type

 

Wobble Pumps

SAE30W

 

non-detergent oil

 

 

Pump Oil Capacity

 

Vertical Wobble Pumps

2..7 fl.. oz..

 

 

Pump Detergent Suction

 

Water to detergent ratio

8 to 1 (12% detergent)

 

 

Water Supply Requirements

 

Minimum inlet pressure

20 psi

Maximum inlet pressure

100 psi

Maximum inlet temperature

100° F

Minimum inlet flow rate

5 gpm

Inlet garden hose size

5/8 inch I..D..

Maximum inlet garden hose length

50 feet

www.chpower.com

10