DeVillbiss Air Power Company LM7580V2C STORAGE OF COMPRESSOR OUTFIT

17—ENG

SERVICE INSTRUCTIONS

Disassembly or service of the air compressor beyond

what is covered in this manual is not recommended.

STORAGE OF COMPRESSOR OUTFIT

1. Review the Maintenance section on the preceding

pages and perform scheduled maintenance as nec-

essary. Drain the water from the air tank.

2. Turn compressor off and disconnect or lock out

power source.

3. Remove any air tool or accessory.

4. Protect the electrical cord and/or air hose from

damage (such as being stepped on or run over).

5. Store the compressor in a clean and dry location.

If additional service is required, contact your nearest

Authorized Warranty Service Center.

Contents

Main OWNERS MANUAL FOR TWO-STAGE AIR COMPRESSOR Model No. LM7580V2C Model No. CALL TOLL FREE 1-800-888-2468, Ext. 2 LM7580V2C Specification Chart TABLE OF CONTENTS SAFETY GUIDELINES - DEFINITIONS HAZARD WHAT CAN HAPPEN HOW TO PREVENT IT SAVE THESE INSTRUCTIONS 3ENG IMPORTANT SAFETY INSTRUCTIONS 4ENG HAZARD RISK OF ELECTRICAL SHOCK RISK OF BURNS RISK FROM FLYING OBJECTS RISK TO BREATHING SPECIFICATIONS GLOSSARY DUTY CYCLE GENERAL INFORMATION ON-RECEIPT INSPECTION DESCRIPTION OF OPERATION Air Compressor Anchoring Methods Vertical Units Location of the Air Compressor Wiring Instructions Voltage and Circuit Protection Wiring of Compressor Units Break-In Procedures Additional Regulators and Controls Lubrication and Oil Piping OPERATING PROCEDURES MAINTENANCE Routine Maintenance Schedule Air Filter - Inspection and Oil - Checking and Changing Oil Chart Check Valve - Inspection and Safety Valve - Inspection and Adjusting Belt Tension Motor Pulley and Flywheel Alignment Additional Service STORAGE OF COMPRESSOR OUTFIT CAUSE CORRECTION PROBLEM Page CORRECTION CAUSEPROBLEM PROBLEM CAUSE CORRECTION COMPRESSOR DIAGRAM COMPRESSOR PARTS LIST Page PUMP PARTS LIST AIR FILTER INSTALLATION LIMITED WARRANTY ONE YEAR FROM DATE OF PURCHASE RESPONSIBILITY OF ORIGINAL PURCHASER (Initial User): THIS WARRANTY DOES NOT COVER: