Hearth and Home Technologies 5100-I Blower Replacement Instructions, Wiring Diagram

Small Red Female

Small Red Female

R

5100-I WOOD INSERT

BLOWER REPLACEMENT INSTRUCTIONS

Part 832-1991 for Serial Numbers 131586 and below Part 832-3190 for Serial Numbers 131587 and above

TOOLS NEEDED: #2 PHILLIPS SCREWDRIVER

1) Unplug blower cord from outlet.

2)Pull insert out from the fireplace.

3)Remove the 2 Air Control spring handles.

4)Remove the lower grill by removing 2 screws in the center of the grill.

5)Unplug the snap disc by-pass switch and speed control from the wiring harness for easier access to blower. (Located on right hand side of stove as you face the unit).

6)Remove screws from blower frame on side of insert.

7)Blower will then slide out through side of insert.

8)Install new blower in same fashion.

9)Re-connect snap disc & speed control to wiring harness and replace screws in blower frame.

10)Re-install lower grill, replace screws & spring handles.

11)Push insert back into the fireplace.

12)Plug blower cord back into outlet.

Remove 2 Spring Handles

Figure 14A

FAN SPEED CONTROL ADJUSTMENT, IF NECESSARY*

*The fan Speed Control for this unit is adjusted at the factory, and normally does not require further adjustment.

NOTE: When the speed control is turned clockwise, it will click on to high speed. Continue to turn the speed control clockwise to decrease the speed. At full clockwise, the blower should blow gently, but should not stop.

1.With the unit plugged in, turn the Speed Control Knob to slow. (Full clockwise.)

2.Use a small screwdriver to adjust the fan speed by turning the adjustment mechanism through the hole on the side of the Speed Control.

3.Adjust the speed so the fan runs slowly but does not stop. Turn clockwise to slow the fan and counterclockwise

to increase the speed.	Small Red Female	Small Red Female
	LEFT FAN	RIGHT FAN

WIRING DIAGRAM

Figure 14B

Large Blue Male

POWER IN

Large Red Female

Large Blue Female Large Blue Female

Large Blue Male

SNAP DISCSPEED

CONTROL

		Large Red Female
Large Blue Male		Large Blue Female
			SNAP DISC
AUX POWER
			BY-PASS SWITCH
LEFT		Large Red Female
	Large Red Female

Page 14 250-1960 Rev B January 30, 2004