New Buck Corporation 42 manual

MODEL 42 MAY BE INSTALLED AS A ZERO CLEARANCE FIREPLACE OR WITH AN OPTIONAL WOODEN SURROUND

WARNING: If the information in this manual is not followed exactly, a fire or

explosion may result causing property damage, personal injury or loss of life.

− Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this

or any other appliance.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any phone in your building.

• Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s

instructions.

• If you cannot reach your gas supplier, call the fire department.

− Installation and service must be performed by a qualified installer, service agency or the

gas supplier.

This is an unvented gas-fired heater. It uses air (oxygen) from the room in which it is in-

stalled. Provisions for adequate combustion and ventilation air must be provided. Refer to

section “ Producing Adequate Ventilation” page 13.

This appliance may be installed in an aftermarket, permanently located, manufactured

(mobile) home, where not prohibited by local codes.

This appliance is only for use with the type of gas indicated on the rating plate. This appli-

ance is not convertible for use with other gases.

Manufacturer: NEW BUCK CORPORATION

P.O. Box 69

8000 Highway 226 South

Spruce Pine, NC 28777

This appliance is intended for supplemental

heating.

Revised December 2006

VENT-FREE

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

Contents

Main MODEL 42 MAY BE INSTALLED AS A ZERO CLEARANCE FIREPLACE OR WITH AN OPTIONAL WOODEN SURROUND Page TABLE OF CONTENTS Page SECTION I SAFETY INFORMATION WARNINGS CAUTION: 19. WARNING: INSTALLATION FOR MODEL 42 (ZC or WS) (E CHOOSING THE LOCATION FOR YOUR FIREPLACE: (ZC or WS) GAS LINES DRAFTS Page INSTALLING THE FIREBOX (ZC) FINISHING YOUR FIREPLACE (ZC) CLEARANCES (ZC) MANTEL PROFILES FOR ZERO CLEARANCE (ZC) CABINET MUST BE FOLLOWED Figure 5 Page 10 INSTALLATION OF MODEL 42 (WS) WITH OPTIONAL WOODEN SURROUND (KIT#PAKDM42) Page PRODUCING ADEQUATE VENTILATION NOTE: DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION VENTILATION AIR VENTILATION AIR FROM INSIDE BUILDING WARNING WARNING: Page WARNING: GAS CONNECTION WARNING: PLACEMENT OF LOGS FOR FP-42-ZC WARNING: GAS PRESSURE CHECK Page EMBER STOVE LOG SET PLACEMENT FOR MODEL 42 WARNING: All previously applied loose material must be removed prior to replacement. WARNING: parts specifically approved with this heater may result in property damage or personal injury. CR3329 CERAMIC LOG SET PLACEMENT FOR MODEL 42 WARNING: LIGHTING INSTRUCTIONS MI LLI VOLT VALVE (I TT) FOR YOUR SAFETY, READ BEFORE LIGHTING WARNING Page TO TURN OFF GAS TO APPLIANCE PILOT BURNER CAUTION IGNITOR ELECTRODE THERMO-PILE THERMOSTAT CONTROL OPERATION MANUAL LIGHTING PROCEDURE LIGHTING INSTRUCTION MODULATING VALVE (SIT) OR MANUAL VALVE (SIT) FOR YOUR SAFETY READ BEFORE LIGHTING WARNING LIGHTING INSTRUCTION TO TURN OFF GAS TO APPLIANCE CAUTION: CAUTION: WARNING: IMPORTANT : THERMOSTAT CONTROL OPERATION MANUAL LIGHTING PROCEDURE LIGHTING INSTRUCTIONS SI T-M ILL IVO LT VALV E FOR YOUR SAFETY READ BEFORE LIGHTING Page CAUTION TO TURN OFF GAS TO APPLIANCE CAUTION: CAUTION: WARNING: Page FLAME CHECK E.S.B. LOG SET DX 2733 SPLIT LOG SET WIRING DIAGRAM WARNING: ROOM BLOWER INSTALLATION AND OPERATION INSTRUCTIONS IMPORTANT SAFEGUARDS WARNING: CLEANING CAUTION: BEFORE CLEANING OR MOVING THESE LOGS OR WARNING: TROUBLE SHOOTING WARNING CAUTION Page Page WARNING SERVICING REPAIR PARTS Page Page REPLACEMENT PARTS Page REPLACEMENT PARTS SIT MILLIVOLT NEW BUCK CORPORATION LIMITED WARRANTY MODEL FP-42-ZC