Safety Alert Symbol, Training | Exmark 4500-996 Rev A manual

Image 5

Exmark 4500-996 Rev A manual Safety Alert Symbol, Safe Operating Practices, Training, Preparation

Contents

For Serial Nos 312,000,000 & Higher PIONEER E-SERIES All Rights Reserved CALIFORNIA Proposition 65 Warning Model No Serial No Introduction Contents Safety Alert Symbol SafetySafety ALERT! YOUR SAFETY IS INVOLVED Avoid prolonged breathing of vapors DANGERKeep face away from nozzle and gas tank/container opening Keep away from eyes and skin Never siphon by mouth Slope Operation OperationAllow engine parts, especially the muffler, to cool before touching Remove accumulated debris from muffler and engine area Maintenance and Storage Using the Rollover Protection System ROPSDo Not mow slopes when grass is wet Lower the roll bar only when absolutely necessary Do Not swallow electrolyte Keep sparks, flames, or cigarettes away from batteryVentilate when charging or using battery in an enclosed space Use cardboard or paper, not your hands, to find hydraulic leaks Safety and Instructional Decals 109-6014 107-2102 116-6363 PTO Switch Symbols116-4308 116-4465 Reverse 109-6016116-4430 Specifications SpecificationsSafety Interlock System Model Numbers Seat Tires & WheelsHydrostatic Ground Drive System Cutting Deck Curb Weight DimensionsTorque Requirements Overall Width Controls Product OverviewOperation Motion Control Levers Throttle Control Ignition SwitchBrake Lever Hour Meter Do Not tow machine PTO Engagement SwitchDrive Wheel Release Valves Operating Instructions Pre-StartDeck Lift Pedal Transport Lock Engaging the PTO Open the Fuel Shut-Off ValveStarting the Engine Disengaging the PTO Use caution when making turnsStopping the Engine Driving the Machine Driving in Reverse Adjusting the Cutting Height Transporting Adjusting the Anti-Scalp RollersTransporting a Unit Do Not drive a unit on a public street or roadway Loading a Unit Use extreme caution when operating a unit on a ramp Maintenance MaintenanceRecommended Maintenance Schedules Check Battery Charge Periodic MaintenanceRecommended Jump Starting Procedure Service Interval Before each use or daily Check Mower Blades Do Not jump start a weak battery if these conditions existBatteries contain acid and produce explosive gases Shield the eyes and face from the batteries at all times SERVICE DEALER Check Safety Interlock System4. Blade bolt washer assembly - Torque to 50-60 ft-lb 1. Spindle 2. Blade 3. Blade drive washer Service Interval After the first 5 hours Service Air CleanerCheck Rollover Protections Systems Roll Bar Knobs Check Seat Belt Note See chart for service intervals Service Interval Every 50 hoursService Interval Every 200 hours Check Tire Pressures Service Interval After the first 100 hours Service Interval Every 500 hoursReplace Emissions Air Intake Filter Change Hydraulic System Filter and Fluid Check Spark Arrester if equipped Do Not refuel or run engine unless spark arrester is installedThread Locking Adhesives Copper-Based Anti-seize Adjusting the Blade Slope AdjustmentsDeck Leveling Blade Slope Deck Belt Tension Adjusting the Parking BrakePump Drive Belt Tension Adjusting the Tilt Motion Control Handle AdjustmentAdjusting the height Motion Control Linkage Adjustment Full Forward Tracking Adjustment Electric Clutch Adjustment Adjusting the Seat Ride SuspensionNo adjustment necessary 8. Tighten nuts Clean Engine and Exhaust System Area CleaningRemove Engine Shrouds and Clean Cooling Fins Clean Hydro Fan Cooling Fins recycling center or according to your state and local regulations Battery Disposal Troubleshooting Troubleshooting Cutting blades is/are bent or unbalanced see Drive Wheel Release Valves section Electrical Diagram SchematicsSchematics Electrical Logic Schematic 1 Year Limited Commercial Warranty Pioneer E-Series Turf Equipment4 Year or 500 Hours Limited Consumer Warranty General Warranty Conditions and Products CoveredPage Page Service Done By Service RecordDate Description of Work DonePage This page may be copied for personal use MID-MOUNT RIDING ACCESSORIES AND OPTIONS SEE EXMARK’S COMPLETE LINE OF ACCESSORIES AND OPTIONSOUT-FRONT RIDING ACCESSORIES AND OPTIONS WALK-BEHIND ACCESSORIES AND OPTIONS

Exmark 4500-996 Rev A Safety Alert Symbol, Safe Operating Practices, Training, Preparation

Models: 4500-996 Rev A