Poulan 411261, 96042003900 Assemble Front Wheel to Mower See Fig, Install Mower and Drive Belt

Page 6

ASSEMBLY

A

FIG. 2

NOTE: You may now roll or drive your tractor off the skid. Follow the appropriate instruction below to remove the tractor from the skid.

WARNING: Before starting, read, understand and follow all instructions in the Operation section of this manual. Be sure tractor is in a well-ventilated area. Be sure the area in front of tractor is clear of other people and objects.

TO ROLL TRACTOR OFF SKID (See Op- eration section for location and function of controls)

•Raise attachment lift lever to its highest position.

•Release parking brake by depressing brake pedal.

•Place freewheel control in disengaged position to dis- engage transmission (See “TO TRANSPORT” in the Operation section of this manual).

•Roll tractor forward off skid.

TO DRIVE TRACTOR OFF SKID (See Op- eration section for location and function of controls)

•Be sure all the above assembly steps have been com- pleted.

•Check engine oil level and fill fuel tank with gasoline.

•Place freewheel control in "transmission engaged" position (see "TO TRANSPORT" in Operation section of this manual).

•Sit on seat in operating position, depress brake pedal and set the parking brake.

•Raise attachment lift lever to its highest position.

•Remove key from bag and start the engine (see "TO START" in the Operation section of this manual). After engine has started, move throttle control to idle (slow) position.

•Release parking brake.

•Slowly depress forward drive pedal and drive tractor off skid.

•Apply brake to stop tractor and set parking brake.

•Turn ignition key to "STOP" position.

Continue with the instructions that follow.

ASSEMBLE FRONT WHEEL TO MOWER (See Fig. 3)

•Using shoulder bolt, washer and locknut from parts bag, assemble front wheel to mower as shown. Tighten

securely.6

FIG. 3

INSTALL MOWER AND DRIVE BELT

(See Figs. 4-12)

See MOWER AND DRIVE BELT ASSEMBLY Supplement Sheet for additional guidance on this assembly.

Be sure tractor is on level surface and engage parking brake.

•Lower attachment lift lever to it's lowest position.

CAUTION: Lift lever is spring loaded. Have a tight grip on lift lever, lower it slowly and engage in lowest position.

•Turn steering wheel to the left as far as it will go and position mower on right side of tractor with deflector shield to the right.

02965

FIG. 4

•Remove plastic tie securing belt, bring belt forward and check belt for proper routing in all mower pulley grooves.

A

FIG. 5

Page 5 Page 7
Image 6
Page 5 Page 7
Contents PB24H54YT ModelSafe Operation Practices for Ride-On Mowers General OperationII. Slope Operation Service III. ChildrenIV. Towing Table of Contents To Remove Tractor from Carton Unpack CartonInstall Mower and Drive Belt Assemble Front Wheel to Mower See FigFirst Install ANTI-SWAY BAR S Check Deck Levelness Check for Proper Position of ALL Belts Leveled. See to Level Mower Housing in the ServiceCheck Tire Pressure Check Brake SystemOperation Ignition Switch Used for starting and stopping the engine Know Your TractorHOW to USE Your Tractor StoppingSystem Characteristics To Adjust Gauge Wheels See FigTo Adjust Mower Cutting Height See Fig To USE Cruise Control -J See FigTo Operate on Hills Service REMINDER/HOUR MeterReverse Operation System ROS To Transport See FigsADD Gasoline Before Starting the EngineCheck Engine OIL Level To Start Engine See FigMowing Tips Maintenance Brake Operation BatteryTractor TiresEngine Muffler CleaningEngine OIL Filter Spark PlugsTo Remove Mower To Install MowerTractor See Fig To Level MowerTurn nut right Turn nut left To raise mower To Replace Mower Blade Drive Belt To Check BrakeTo Replace Motion Drive Belt To Remove Wheel for Repairs See Fig To Start Engine with a Weak Battery See FigFront Wheel TOE-IN/CAMBER To Attach Jumper CablesTo Adjust Carburetor To Adjust Throttle Control CableTo Adjust Choke Control To Replace Headlight BulbEngine OIL OtherFuel System CylindersTroubleshooting Points Weak or dead battery Recharge or replace batteryBrake pedal not depressed Depress brake pedal Clean underside of mower housing Check wiring, switches and connections. If notCorrected, contact an authorized service center Clean around mandrels to open vent holesLimited Warranty L5T 1K6Suggested Guide for Sighting Slopes for Safe Operation Service Notes Service Notes Parts and Service Changere DE Pièces LES ET L’ENTRETIEN Pente Pliez EST Dentretien Notes Dentretien Notes Autorisé Garantie cette de exclus sont normal l’entretien etInitiale d’achat date la de compter à jours 90 dix Dépannage DE Guide Connexions les et interrupteurs les câblage, le VérifiezLame de mandrin le Remplacez Tordu est lame de mandrin Un Entreposage Reglages ET Revision Starter DU Commande LA Régler PourGAZ DES Commande Carburateur LE Régler PourFig la Voir Tionsraparé LES Pour Roues LES Enlever Pour AvantRoue LA DE PINCEMENT/CARROSSAGE Freins LES Vérifier Pour Courroie Acer Rempl Pour’ENTRAÎNEMENT DeuseAVANT/ARRIÈRE Ajustement 31 .FIG30 .FIG 29 .FIGTondeuse LA Niveau LE Ajuster Pour Tondeuse LA Installer PourFig la Voir Tondeuse LA Enlever Pour’ALLUMAGE Bougie Ligne EN Installe Dessence FiltreEntretien Moteur DE D’HUILE FiltreLubrification AIR À Filtre’AIR Tamis LE Nettoyer Sionmistrans LA DE Moteur FluideFig la Voir Lame LA Enlever EN Fonctionnement DE Système ETLubrification DE Tableau Utilisation Chaque AvantTransmission LA Purger Avant ET Réinstallation LA Après Purgée ÊtreUtilisation 22 .FIGMoteur DU D’HUILE Niveau LE Vérifier Moteur LE Démarrer Pour’ESSENCE Réservoir LE Remplir QuetimaautoPentes LES Dans Utiliser Pour Accessoires Autres ET Charrettes DES Remorquer Pour’ENTRETIEN/HOROMÈTRE Indicateur 21 et 13 .Fig les VoirFig la Voir J- Vitess DE Régulateur LE Utiliser Comment Tondeuse LA Utiliser PourJauge DE Roues LES Régler Pour Fig la Voir Mentnetionsta DE Frein LE Engager Pour GAZ DES Commande LA Utiliser PourFig la Voir Arrêter Pour Reculer Pour ET Avancer PourFroid moteur un démarrer de permet Détrangleur Commande N Moteur de vitesse la commander de permet GAZ DES Commande D13 .FIG ’EMBRAYAGE Montage ROULIS-ANTI Barre LA D’ABORD Installez 10 .FIGLA DE Latéraux Suspension DE Bras LES Fixez LA DE Tracteur LE Retirer Pour Figs les Voir D’ENTRAÎNEMENTDesmancom des tionfonc la et Desmancom des fonction la etMontées NON Piéces Toncar DU Tracteur LE Sortir PourCCA .MIN AMP/HR U1R DimensionSommaire SL-SG-APIEn l’utilisation pour Conseils Général EntretienTracteurs des sécurité toute ’ESSENCE DE Sûre ManipulationPentes LES Dans FonctionnementTracteurs des sécurité toute en l’utilisation pour Conseils Pelouse DE Tracteur PB24H54YT Modèle Propriétaire DU Manuel
Top Page Image Contents