Poulan 184433, 954569677 manual Tractor Model Number POGT20T48STA, Product no 56, Schematic

Page 29

TRACTOR - MODEL NUMBER POGT20T48STA, PRODUCT NO. 954 56 96-77

SCHEMATIC

RED

BLACK

BATTERY

	A		RED
	A
AMMETER			FUSE
AMMETER
(OPTIONAL)
			WHITE
RED	B	S
		S
		M	CLUTCH / BRAKE
	G		CLUTCH / BRAKE
	G	A1	(PEDAL UP)
	L	A2
BLACK	IGNITION
BLACK	SWITCH
	SWITCH

SEAT SWITCH

(NOT OCCUPIED)

RED M

STARTER

BLACK

SOLENOID

C G

F

H

B

E

A	ELECTRIC CLUTCH

D

PTO (DISENGAGED)

85 86

FUEL

BLUELINE

FUEL SHUT-OFF

SOLENOID

(IF SO EQUIPPED)

87

30

		87A
		OPERATOR PRESENCE
		RELAY #1
		SPARK
BLACK	IGNITION	PLUG
	UNIT	GAP
	UNIT	(2 PLUGS ON
		(2 PLUGS ON
		TWIN CYL. ENGINES)

HOUR

METER		CHARGING SYSTEM OUTPUT	28 VOLTS AC @ 3600 RPM
		16 AMP DC @ 3600 RPM	(REGULATOR DISCONNECTED)
(OPTIONAL)	RED
	RED	REGULATOR
		REGULATOR
BROWN	BLACK		ALTERNATOR
BROWN	BLACK

IGNITION SWITCH

POSITION	CIRCUIT	“MAKE”


OFF	M+G+A1	NONE
RUN/LIGHT	B+A1	A2+L
RUN	B+A1	NONE
START	B + S + A1	NONE

HEAD-

LIGHTS

PTO SWITCH

POSITION	CIRCUIT


OFF	C + G, B + H
ON	C + F, B + E, A + D

REMOVABLE NON-REMOVABLE

CONNECTIONS CONNECTIONS

WIRING INSULATED CLIPS

NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.

H

G F C

E

D A

B

29

Image 29

Contents Model NO. POGT20T48STA Safe Operation Practices for Ride-On Mowers IV. ServiceGeneral Operation II. Slope OperationSafety Rules Table of Contents Unassembled Parts Tools Required for Assembly AssemblyHOW to SET UP Your Tractor To Remove Tractor from CartonAssemble Gauge Wheels to Mower Deck See Fig Install Seat See FigInstall Mower and Drive Belt See Figs Check for Proper Position of ALL Belts Check Tire PressureCheck Mower Levelness Operation 02734 Know Your TractorHOW to USE Your Tractor To Operate Mower See Fig To Adjust Gauge Wheels See FigTo Operate on Hills To TransportTowing Carts and Other ATTACH- Ments Before Starting the EngineCheck Engine OIL Level ADD GasolineMowing Tips Before Each USE MaintenanceGeneral Recommendations Tractor Engine Clean AIR ScreenBelts Transaxle CoolingCleaning To Install Mower Service and AdjustmentsTo Replace Mower Drive Belt To Level Mower HousingTo Replace Mower Blade Secondary Drive Belt See Fig To Check and Adjust Brake See FigTo Adjust Steering Wheel Alignment Transaxle Gear Shift Lever NEUTRAL- Adjustment See FigTo Replace Motion Drive Belt See Fig Front Wheel TOE-IN/CAMBERTo Replace Headlight Bulb To Remove Wheel for Repairs See FigInterlocks and Relays To Replace FuseTo Adjust Throttle Control Cable To Remove Hood and Grill Assembly See FigTo Adjust Choke Control To Adjust CarburetorFuel System OtherEngine OIL CylindersProblem Cause Correction Troubleshooting PointsOFF Tractor Model Number POGT20T48STA, Product no 56 SchematicElectrical KEY Part Description Chassis and Enclosures Repair Parts Drive Repair Parts Steering Assembly Repair Parts Engine Repair Parts Seat Assembly Wheels & Tires DecalsMower Lift Repair Parts Mower Deck Repair Parts Limited Warranty Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe Operation