Poulan 96042007000 Install Mower and Drive Belt, Roll tractor forward off skid, Tighten securely

Page 6

ASSEMBLY

A

FIG. 2

NOTE: You may now roll or drive your tractor off the skid. Follow the appropriate instruction below to remove the tractor from the skid.

WARNING: Before starting, read, understand and follow all instructions in the Operation section of this manual. Be sure tractor is in a well-ventilated area. Be sure the area in front of tractor is clear of other people and objects.

TO ROLL TRACTOR OFF SKID (See Op- eration section for location and function of controls)

•Raise attachment lift lever to its highest position.

•Release parking brake by depressing brake pedal.

•Place freewheel control in disengaged position to disengage transmission (See “TO TRANSPORT” in the Operation section of this manual).

•Roll tractor forward off skid.

TO DRIVE TRACTOR OFF SKID (See Op- eration section for location and function of controls)

•Be sure all the above assembly steps have been completed.

•Check engine oil level and fill fuel tank with gasoline.

•Place freewheel control in "transmission engaged" position (see "TO TRANSPORT" in Operation sec- tion of this manual).

•Sit on seat in operating position, depress brake pedal and set the parking brake.

•Raise attachment lift lever to its highest position.

•Remove key from bag and start the engine (see "TO START" in the Operation section of this manual). After engine has started, move throttle control to idle (slow) position.

•Release parking brake.

•Slowly depress forward drive pedal and drive trac- tor off skid.

•Apply brake to stop tractor and set parking brake.

•Turn ignition key to "STOP" position.

Continue with the instructions that follow.

ASSEMBLE FRONT WHEEL TO MOWER (See Fig. 3)

•Using shoulder bolt, washer and locknut from parts bag, assemble front wheel to mower as shown.

Tighten securely.

6

 

FIG. 3

INSTALL MOWER AND DRIVE BELT

(See Figs. 4-12)

See MOWER AND DRIVE BELT ASSEMBLY Supplement Sheet for additional guidance on this assembly.

Be sure tractor is on level surface and engage park- ing brake.

•Lower attachment lift lever to lowest position.

CAUTION: Lift lever is spring loaded. Have a tight grip on lift lever, lower it slowly and engage in lowest position.

•Turn steering wheel to the left as far as it will go and position mower on right side of tractor with deflector shield to the right.

02965

FIG. 4

•Remove plastic tie securing belt, bring belt forward and check belt for proper routing in all mower pul- ley grooves.

A

FIG. 5

Page 5 Page 7
Image 6
Page 5 Page 7
Contents PB22H54BFX ModelSafe Operation Practices for Ride-On Mowers General OperationII. Slope Operation III. Children ServiceGeneral Service IV. TowingTable of Contents To Remove Tractor from Carton Unpack CartonInstall Mower and Drive Belt Roll tractor forward off skidTighten securely First Install ANTI-SWAY BAR S Pivot bar towards you and insert other end of barCheck for Proper Position of ALL Belts Check Tire PressureCheck Deck Levelness Check Brake SystemOperation Know Your Tractor Reverse Operation System ROS on PositionStopping HOW to USE Your TractorTo SET Parking BRAKESee Fig To USE Throttle Control See FigCruise control feature can be used for forward travel only To Adjust Mower Cutting Height See FigTo Adjust Gauge Wheels See Fig To Move Forward and Backward N See FigTo Operate on Hills To Operate MowerReverse Operation System ROS To Transport See FigsCheck Engine OIL Level Service REMINDER/HOUR MeterBefore Starting the Engine ADD GasolineMowing Tips Purge TransmissionLubrication Chart Before Each USEBrake Operation BatteryTractor TiresEngine Muffler CleaningEngine OIL Filter Spark PlugsTo Remove Mower To Install MowerTractor See Fig To Level MowerPrecision SIDE-TO-SIDE Adjustment See Fig To Replace Mower Blade Drive Belt To Check BrakeTo Replace Motion Drive Belt To Start Engine with a Weak Battery See Fig Front Wheel TOE-IN/CAMBERTo Remove Wheel for Repairs See Fig To Adjust Carburetor To Adjust Throttle Control CableTo Adjust Choke Control To Replace Headlight BulbEngine OIL OtherFuel System CylindersTroubleshooting Points Problem Cause CorrectionMower blades will not Outdoor Products Customer Service Dept HOPCanada contact Suggested Guide for Sighting Slopes for Safe Operation Service Notes Service Notes Parts and Service Changere DE Pièces LES ET L’ENTRETIEN Dentretien Notes Dentretien Notes Degrés Suivant LES Pliez ESTDept Service Customer Products Outdoor Acheté l’avez vous qui chez autorisé concessionnaireCanada Au Dépannage DE Guide Correction Cause ProblèmeLa réduisez ou haute plus coupe de position en Mettez Entreposage Reglages ET Revision Starter DU Commande LA Régler PourGAZ DES Commande LA DE Câble LE Régler Pour Carburateur LE Régler PourFig la Voir Tionsraparé LES Pour Roues LES Enlever Pour AvantRoue LA DE PINCEMENT/CARROSSAGE LA DE Lame LA DE D’ENTRAÎNEMENT ’ENTRAÎNEMENTCourroie Acer Rempl Pour Courroie a L Acer Rempl PourAVANT/ARRIÈRE Ajustement Tondeuse LA Niveau LE Ajuster Pour Tondeuse LA Installer PourFig la Voir Tondeuse LA Enlever PourMoteur DE D’HUILE Filtre Ligne EN Installe Dessence FiltreEntretien NettoyageLubrification AIR À Filtre’AIR Tamis LE Nettoyer Sionmistrans LA DE Moteur FluideFig la Voir Lame LA Enlever Lames DES EntretienEN Fonctionnement DE Système ET Généra Recommandations LES Lubrification DE TableauUtilisation Chaque Avant Utilisation Transmission LA Purger22 .FIG Moteur DU D’HUILE Niveau LE Vérifier Moteur LE Démarrer Pour’ESSENCE Réservoir LE Remplir Quetima’ENTRETIEN/HOROMÈTRE Indicateur 21 et 13 .Fig les VoirMAR EN Fonctionnement DE Système Jauge DE Roues LES Régler Pour Fig la Voir J- Vitess DE Régulateur LE Utiliser CommentTondeuse LA Utiliser Pour Système DU CaractéristiquesTionsta DE Frein LE Engager Pour GAZ DES Commande LA Utiliser PourFig la Voir Mentne Reculer Pour ET Avancer Pour13 .FIG ’EMBRAYAGE Montage NI DE EST Tondeuse LA SI VérifierROULIS-ANTI Barre LA D’ABORD Installez 10 .FIGPA LA DE Tracteur LE Retirer Pour PAL LA DE Tracteur LE Retirer PourMontées NON Piéces Toncar DU Tracteur LE Sortir PourUtilisation SommaireGarantie ’ENTRETIEN Guide Réglages ET Révision Produit DE SpécificationsEn l’utilisation pour Conseils Général EntretienTracteurs des sécurité toute ’ESSENCE DE Sûre ManipulationTES Tracteurs des sécurité toute en l’utilisation pour ConseilsOpérez vous lorsque prudent très Soyez .mortelles même Avertissement
Top Page Image Contents