Poulan PO165H42STB manual Repair Parts

Page 31

REPAIR PARTS

TRACTOR - - MODEL NUMBER PO165H42STB, PRODUCT NO. 954 56 78-19

CHASSIS AND ENCLOSURES

KEY	PART
NO.	NO.	DESCRIPTION
1	174619	Chassis
2	176554	Drawbar
3	17060612	Screw 3/8-16 x 3/4
5	155272	Bumper Hood/Dash

9168336X010 Dash

1072140608 Bolt RdHd Sqnk. 3/8-16 Unc x 1

11174996 Panel Asm. Dash Lh

12

145660

Clip Tinnerman Grile P/L

13172105X010 Panel Dash Rh

1417490608 Screw Thdrol 3/8-16 x 1/2

17159639X428 Hood

18 126938X Bumper Hood

2474780616 Bolt Fin Hex 3/8-16 Unc x 1 Gr. 5

2519131312 Washer 13/32 x 13/16 x 12 Ga.

2673800600 Nut Lock Hex w/Insert 3/8-16 UNC

28 179101

Grill/Lens Asm

29140273X599 Lens Grille Private label

30169468X428 Fender Asm

31	136619	Bracket Fender
33	179716X428	Footrest LH
34	179717X428	Footrest RH
35	72110606	Bolt RdHd Sht. Sqnk. 3/8-16 x 3/4

3717490508 Screw Thdrol 5/16-18 x 1/2 Tyt

38175710 Bracket Asm. Pivot Mower Rear

5173800400 Nut Lock Hex W/Ins. 1/4-20

5219091416 Washer 9/32 x 7/8 x 16 Ga.

53	144697	Bracket Grille LH
54	161464	Screw Hex Wshd 8-18 x 7/8
55	144696	Bracket, Grille RH

5774780412 Bolt Fin Hex 1/4-20 x .75

58150127 Air Duct Private Label

64	154798	Dash Lower
142	175702	Plate Reinforcement
145	156524	Rod Pivot Chassis/Hood
206	170165	Bolt shoulder 5/16-18

20717670508 Screw Thdrol 5/16-18 x 1/2

20817670608 Screw Thdrol 3/8-16 x 1/2

212	156229	Insert Lens Reflector
- -	5479J	Plug Btn Blk

NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm

31

Image 31

Contents Model NO. PO165H42STB II. Slope Operation IV. ServiceSafe Operation Practices for Ride-On Mowers General OperationSafety Rules Table of Contents Slope Sheet Unassembled PartsSteering Wheel Seat KeyTo Remove Tractor from Carton AssemblyTools Required for Assembly HOW to SET UP Your TractorLower seat into operating position and sit on seat Install Seat See FigCheck Brake System Check Tire PressureCheck Deck Levelness Check for Proper Position of ALL BeltsOperation Know Your Tractor HOW to USE Your Tractor To Transport See Figs To Adjust Gauge Wheels See FigTo Operate Mower See Fig To Operate on HillsTo Start Engine See Fig Before Starting the EngineCheck Engine OIL Level ADD GasolineMowing Tips General Recommendations Lubrication ChartService Dates Customer ResponsibilitiesTractor Engine Muffler CleaningSpark Plugs To Remove Mower See Fig Service and AdjustmentsTo Install Mower See Fig To Level Mower HousingBelt Removal To Adjust Brake See FigBelt Installation To Replace Mower Blade Drive Belt See FigTransmission REMOVAL/REPLACEMENT Transaxle Motion Control Lever Neutral Adjustment See FigTo Replace Motion Drive Belt See Fig Front Wheel TOE-IN/CAMBER To Adjust Steering Wheel AlignmentTo Start Engine with a Weak Battery See Fig Replacing Battery See FigsTo Replace Fuse To Adjust CarburetorTo Replace Headlight Bulb Interlocks and RelaysEngine OIL StorageOther Fuel SystemTroubleshooting Points OFF Tractor - Model Number PO165H42STB, Product no 56 SchematicElectrical KEY Part Description Chassis and Enclosures Repair Parts Drive Repair Parts Steering Assembly KEY Part NO. NO. Description Engine 148315 Seat Assembly Wheels & Tires DecalsMower Lift Nut Lock w/Wsh 1/2-13 Unc Mower Deck 177563 Service Notes Service Notes Limited Warranty Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe Operation