Poulan PD15538LT manual To Replace Headlight Bulb, Interlocks and Relays, To Replace Fuse

Page 23

SERVICE AND ADJUSTMENTS

REPLACING BATTERY (See Figs. 24 and 25)

WARNING: Do not short battery terminals by allowing a wrench or any other object to contact both terminals at the same time. Before connect- ing battery, remove metal bracelets, wristwatch bands, rings, etc.

Positive terminal must be connected first to prevent sparking from acci- dental grounding.

•Lift seat pan to raised position.

•Disconnect BLACK battery cable fi rst then RED battery cable and carefully remove battery from tractor.

•Install new battery with terminals in same position as old battery.

•First connect RED battery cable to positive (+) terminal with hex bolt and keps nut as shown. Tighten securely. Slide terminal cover over terminal.

•Connect BLACK grounding cable to negative (-) ter- minal with remaining hex bolt and keps nut. Tighten securely.

SEAT PAN

FIG. 24

TERMINAL

KEPS NUT

COVER

 

HEX

BOLT

POSITIVE (RED) CABLE

NEGATIVE (BLACK) CABLE

FIG. 25

TO REPLACE HEADLIGHT BULB

•Raise hood.

•Pull bulb holder out of the hole in the backside of the grill.

•Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill.

•Close hood.

INTERLOCKS AND RELAYS

Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting.

•Check wiring. See electrical wiring diagram in the Repair Parts section.

TO REPLACE FUSE

Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash.

TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 26)

•Raise hood.

•Unsnap headlight wire connector.

•Stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor.

•To replace, reverse above procedure.

HOOD

HEADLIGHT WIRE

CONNECTOR

01536

FIG. 26

ENGINE

TO ADJUST THROTTLE CONTROL CABLE

The throttle control has been preset at the factory and adjustment should not be necessary. If adjustment is nec- essary, see engine manual.

TO ADJUST CHOKE CONTROL

The choke control has been preset at the factory and ad- justment should not be necessary. If adjustment is neces- sary, see engne manual.

TO ADJUST CARBURETOR

Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.

23

Page 22 Page 24
Image 23
Page 22 Page 24
Contents Always Wear EYE Protection During Operation PD15538LTII. Slope Operation Safety RulesSafe Operation Practices for Ride-On Mowers General OperationIV. Towing ServiceGeneral Service III. ChildrenTable of Contents Contents of Hardware Pack Before Removing Tractor from Skid AssemblyTools Required for Assembly To Remove Tractor from CartonCheck Battery See Fig Check Brake System Check Tire PressureCheck Deck Levelness Check for Proper Position of ALL BeltsOperation Know Your Tractor HOW to USE Your Tractor To Transport Reverse Operation System ROSTo Operate Mower See Fig To Operate on HillsTo Start Engine See Fig Before Starting the EngineCheck Engine OIL Level ADD GasolineMowing Tips Before Each USE MaintenanceLubrication Chart General RecommendationsTo Sharpen Blade See Fig TractorBlade Removal See Fig Transaxle Cooling BatteryEngine BeltsMuffler CleaningClean AIR Screen AIR FilterTo Remove Mower See Fig Service and AdjustmentsTo Install Mower See Fig Belt Removal To Level Mower HousingBelt Installation To Replace Mower Blade Drive Belt See FigTo Check Brake To Check and Adjust Brake See FigTo Adjust Brake To Replace Motion Drive Belt See FigFront Wheel TOE-IN/CAMBER Transaxle Gear Shift Lever NEUTRAL- Adjustment See FigTo Adjust Steering Wheel ALIGN- Ment To Start Engine with a Weak Battery See FigTo Replace Headlight Bulb To Adjust Throttle Control CableTo Adjust Choke Control To Adjust CarburetorEngine OIL StorageOther Fuel SystemProblem Cause Correction Troubleshooting PointsEngine dies when Limited Warranty Policy Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationParts and Service

PD15538LT specifications

The Poulan PD15538LT is a versatile and powerful lawn tractor designed to simplify lawn care tasks and maximize efficiency for homeowners with medium to large yards. This model stands out for its robust features, ease of use, and innovative technologies that enhance its performance, making it an excellent choice for those looking to maintain a pristine landscape.

One of the PD15538LT's standout features is its powerful 15.5 horsepower Briggs & Stratton engine, which provides ample power to tackle various mowing conditions. The engine is designed for easy starting and smooth operation, ensuring users can get to work quickly without hassle. Coupled with a 38-inch cutting deck, the tractor allows for efficient mowing, enabling you to cover more ground in less time while delivering a clean and even cut.

The mowing deck is equipped with three adjustable cutting heights, allowing users to customize the grass length according to their preferences or seasonal requirements. This feature is particularly beneficial for maintaining healthy turf throughout the growing seasons. Additionally, the PD15538LT utilizes a front-mounted cutting system that enhances visibility while mowing, making it easier to navigate around obstacles such as trees, flower beds, and garden décor.

Another significant characteristic is the automatic transmission, which allows for seamless speed adjustments without the need for manual shifting. This feature offers a smooth and comfortable riding experience, enabling users to focus on mowing without worrying about gear changes. The tractor also features a tight turning radius, making it agile enough to maneuver in tight spaces.

The Poulan PD15538LT incorporates innovative technologies such as a durable steel frame that enhances stability and longevity, ensuring it withstands the rigors of regular use. The easy-access controls are designed for user convenience, allowing operators to adjust settings intuitively, enhancing the overall mowing experience.

Furthermore, this lawn tractor is compatible with various attachments, such as mulching kits and baggers, increasing its versatility for different lawn care tasks. Overall, the Poulan PD15538LT is an excellent investment for homeowners seeking a reliable and efficient lawn tractor that combines power, ease of use, and innovative features, ensuring a well-maintained lawn with minimal effort.
Top Page Image Contents