Poulan 96012008100, 417905 manual Table of Contents

Page 4

PRODUCT SPECIFICATIONS

Gasoline Capacity	1.50 Gallons
and Type:	Unleaded Regular
Oil Type (API-SG-SL):	SAE 30 (above 32°F)
	SAE 5W-30 (below 32°F)
Oil Capacity:	W/Filter:		56 oz
	W/O Filter: 48 oz
Spark Plug:	Champion RC12YC
	(Gap: .030")
Ground Speed (MPH):	Forward:
	1st	1.1
	2nd	1.4
	3rd	2.2
	4th	3.4
	5th	4.3
	6th	5.5
Reverse:		1.7
Charging System:	3 Amps Battery
	5 Amps Headlights
Battery:	AMP/HR:		28
	Min. CCA:		230
	Case Size:		U1R
Blade Torque:	45-55 FT. LBS.

CONGRATULATIONS on your purchase of a new tractor. It has been designed, engineered and manufactured to give you the best possible dependability and performance.

Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/department. We have competent, well-trained technicians and the proper tools to service or repair this tractor.

Please read and retain this manual. The instructions will enable you to assemble and maintain your tractor properly. Always observe the “SAFETY RULES”.

CUSTOMER RESPONSIBILITIES

•Read and observe the safety rules.

•Follow a regular schedule in maintaining, caring for and using your tractor.

•Follow the instructions under “Maintenace” and “Stor- age” sections of this owner’s manual.

WARNING: This tractor is equipped with an internal com- bustion engine and should not be used on or near any un- improved forest-covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.

A spark arrester for the muffler is available through your nearest authorized service center/department.

In the state of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands.

TABLE OF CONTENTS

SAFETY RULES	2-3
PRODUCT SPECIFICATIONS	4
CUSTOMER RESPONSIBILITIES	4
ASSEMBLY	6-8
OPERATION	9-14

MAINTENANCE SCHEDULE	15
MAINTENANCE	15-18
SERVICE AND ADJUSTMENTS	19-23
STORAGE	24
TROUBLESHOOTING	25-26
WARRANTY	27

4

Image 4

Contents Model PBA19542LTSafety Rules Safe Operation Practices for Ride-On MowersGeneral Operation II. Slope OperationIII. Children ServiceIV. Towing Table of Contents Unassembled Parts Steering WheelSeat KeysAssembly Tools Required for AssemblyTo Remove Tractor from Carton Before Removing Tractor from SkidInstall Seat See Fig Check Battery See FigCheck Tire Pressure Check Deck LevelnessCheck for Proper Position of ALL Belts Check Brake SystemOperation Know Your Tractor HOW to USE Your Tractor Reverse Operation System ROS To Operate Mower See FigTo Operate on Hills Before Starting the Engine To TransportCheck Engine OIL Level ADD GasolineMowing Tips Maintenance General RecommendationsBefore Each USE Check Brake Operation Check Tire PressureTractor Blade Removal See FigTo Sharpen Blade See Fig Check Operator Presence SystemEngine Cleaning Clean AIR ScreenAIR Filter MufflerService and Adjustments To Install Mower See FigTo Level Mower Housing To Remove Mower See FigRecheck side-to-side adjustment Belt Installation To Check BrakeTo Replace Mower Blade Drive Belt See Fig To Replace Motion Drive Belt See FigTransaxle Gear Shift Lever NEUTRAL- Adjustment See Fig To Start Engine with a Weak Battery See FigTo Adjust Steering Wheel ALIGN- Ment Front Wheel TOE-IN/CAMBERTo Adjust Throttle Control Cable To Adjust CarburetorTo Replace Headlight Bulb Interlocks and RelaysStorage OtherFuel System Engine OILTroubleshooting Points Problem Cause CorrectionEngine dies when Outdoor Products Customer Service Dept HOPCanada contact Stevens Creek Road Terry Fox Way Augusta, GA 30907 USAService Notes Suggested Guide for Sighting Slopes for Safe Operation Parts and Service Changere DE Pièces LES ET L’ENTRETIEN Degrés Suivant LES UNE Pliez EST Ceci’ENTRETIEN Remarques Autorisé Dept Service Customer Products Outdoor Canada AuGarantie cette de exclus sont normal l’entretien et Dépannage DE Guide Conducteur le lorsqueLame de mandrin le Remplacez Tordu est lame de mandrin Un Moteur EntreposageTracteur Reglages ET Revision MoteurRossage -AVANT/CAR Roues DES Convergence LA DE L’ALIGNEMENT Régler PourFig la Voir Vitesses DE Boîte LA DE Mentge’EN Courroie LA Remplacer Pour Fig la VoirCourroie Acer Rempl Pour Tondeuse DE Boîtier LE Niveler Pour 19 .FIG18 .FIG 17 .FIGTracteur 15 .FIGEntretien ’ALLUMAGE BougieAIR À Filtre ’AIR Tamis LE NettoyerSionmistrans LA DE Moteur Fluide Transmission LA DE RefroidissementFig la Voir Lame LA Affiler Trapézoïdales CourroiesFig la Voir Lame LA Enlever EN Fonctionnement DE Système ETRecommandations LES GénéralesLubrification DE Tableau Utilisation Chaque AvantTondre DE Conseils UtilisationAvec marcher le-faites moteur, le démarrez vous Quand Moteur LE Démarrer DE Avant Fonction DE Système DU Utilisation Pentes LES Dans Utiliser PourMAR EN Fonctionnement DE Système GAZ DES Commande LA Utiliser Pour Teurtrac Votre Utiliser CommentReculer Pour ET Avancer Pour Fig la Voir Arrêter PourLSW02838 ’EMBRAYAGE Montage Desmancom des tionfonc la etTionsec la Voir Conduisant LE EN Lette PA LA DE Tracteur LE Retirer PourFig la Voir Siège LE Installer Votre Monter CommentDesman Com des fonction la et mentceplalemPalette LA DU Tracteur LE Sortir PourToncar Montées NON Piéces Pente-GuideSommaire Client DU ResponsabilitésProduit DE Spécifications CCA .MIN AMP/HREntretien RemorquageEnfants Général EntretienTES PEN LES Dans FonctionnementGénéral Fonctionnement Tracteurs des sécurité toute en l’utilisation pour ConseilsCom.poulan.www web site notre Visitez ModèleAUX Imprimé