Poulan 96042003503 manual To Replace Mower Blade Drive Belt See Fig, To Check Brake, Belt Removal

Page 22

SERVICE AND ADJUSTMENTS

TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 31)

The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake.

BELT REMOVAL -

•Remove mower from tractor (See “TO REMOVE MOWER” in this section of manual).

•Work belt off both mandrel pulleys and idler pulleys.

•Pull belt away from mower.

BELT INSTALLATION -

•Work belt around both mandrel pulleys and idler pulleys.

•Make sure belt is in all pulley grooves and inside all belt guides.

•Install mower (See "To Install Mower" in this section of manual).

MANDRELIDLER

PULLEYPULLEYS

MANDREL

PULLEY

FIG. 31

TO CHECK BRAKE

If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be serviced.

You may also check brake by:

•Park tractor on a level, dry concrete or paved surface, depress brake pedal all the way down and engage parking brake.

•Place gear shift lever in neutral position.

The rear wheels must lock and skid when you try to manu- ally push the tractor forward. If the rear wheels rotate, then the brake needs to be serviced. Contact a qualified service center.

TO REPLACE MOTION BELT DRIVE (See Fig. 32)

Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest.

BELT REMOVAL -

•Remove mower (See “TO REMOVE MOWER” in this section of manual).

NOTE: Observe entire motion drive belt and position of all belt guides and keepers.

•Remove belt from stationary idler (A) and clutching idler (B).

•Pull belt slack toward rear of tractor. Carefully remove belt upwards from transmission input pulley and over cooling fan blades (D).

•Remove belt downward from engine pulley (E).

•Slide belt toward rear of tractor, off the steering plate

(F) and remove from tractor.

BELT INSTALLATION -

•Install new belt from tractor rear to front, over the steer- ing plate (F) and above clutch brake pedal shaft (G).

•Pull belt toward front of tractor and roll belt onto engine pulley (E).

•Pull belt toward rear of tractor. Carefully work belt down around transmission cooling fan and onto the input pulley (D). Be sure belt is inside the belt keeper.

•Install belt through stationary idler (A) and clutching idler (B).

•Make sure belt is in all pulley grooves and inside all belt guides and keepers.

•Install mower (See “TO INSTALL MOWER” in this section of manual).

E

F

A

G

B

D

02954

Manual

FIG. 32

22

Page 21 Page 23
Image 22
Page 21 Page 23
Contents PB19546LT ModelGeneral Operation Safety RulesSafe Operation Practices for Ride-On Mowers II. Slope OperationIII. Children ServiceGeneral Service IV. TowingTable of Contents Unassembled Parts Key Slope SheetTo Remove Tractor from Carton AssemblyTools Required for Assembly Before Removing Tractor from SkidInstall Seat See Figs Check Battery See FigCheck for Proper Position of ALL Belts Check Tire PressureCheck Deck Levelness Check Brake SystemOperation Know Your Tractor To SET Parking Brake See Fig HOW to USE Your TractorAttachment Clutch Switch Disengaged Engaged Stopping See FigsUsing the Reverse Operation System To Adjust Mower Cutting Height See FigTo Adjust Gauge Wheels See Fig To Move Forward and Backward See FigBefore Starting the Engine Mowing Tips To Start Engine See FigMaintenance Lubrication ChartTractor BatteryBlade Removal See Fig Belts EngineLubrication Transaxle CoolingCleaning To Install Mower See Figs Service and AdjustmentsTo Remove Mower See Fig Install belt on engine pulley M To Level Mower To Check Brake Belt InstallationTo Replace Mower Blade Drive Belt See Fig To Replace Motion Belt Drive See FigTo Start Engine with a Weak Battery See Fig Transaxle Gear Shift Lever NEUTRAL- Adjustment See FigTo Adjust Steering Wheel ALIGN- Ment Front Wheel TOE-IN/CAMBERTo Adjust Carburetor To Adjust Throttle Control CableTo Adjust Choke Control To Replace Headlight BulbFuel System StorageOther Engine OILTroubleshooting Points Problem Cause CorrectionEngine dies when Service Notes Only Ride UP and Down Hill Not Across Hill Degrees MAX Fold Alon THI Dotted Line REE LopePage Page Degrés ’ENTRETIEN Remarques Dépannage DE Guide Correction Cause ProblèmeRalenti Entreposage Réglages ET Révision Starter DU Commande LA Régler PourGAZ DES Commande LA DE Câble LE Régler Pour Carburateur LE Régler PourTionrecdi LA DE L’ALIGNEMENT Régler Pour Fig la Voir Tionsraparé LES Pour Roues LES Enlever PourCarrossage AVANT/ Roues DES Convergence 33 .FigTondeuse DE Lame DE Mentnetraî FIG LA Voir D’ENTRAÎNEMENT Courroie a L Acer Rempl PourFIG LA Voir ’EN Courroie LA Remplacer Pour29 .FIG Tondeuse LA Niveau LE Ajuster Pour30 .FIG 28 .FIG23 .FIG 26 .FIG25 .FIG 22 .FIGFig Voir Courroie LA ET Tondeuse LA InstallerReglages ET Revision Tondeuse LA Enlever PourEntretien Trapézoïdales Courroies Transmission LA DE Refroidissement19 ET 18 .FIGS LES Voir Moteur DE L’HUILE Changer Pour LubrificationLames DES Entretien Fig la Voir Lame LA AffilerFig la Voir Lame LA Enlever PneusLubrification DE Tableau O I T a D N a M M O C E RUtilisation Chaque Avant Tonte DE Conseils UtilisationMoteur LE Démarrer Pour 14 .FIGMoteur DU D’HUILE Niveau LE Vérifier Accessoires Autres’ESSENCE Réservoir LE Remplir ET Charrettes DES Remorquer Pour11 .FIG Fig la Voir Reculer Pour ET Avancer PourJauge DE Roues LES Régler Pour 10 .FIGEt 7 .Figs la Voir Arrêter Pour GAZ DES Commande LA Utiliser PourFig la Voir Mentne -TIONSTA DE Frein LE Engager Pour Dattachement Propriété la de lendommagement Toutes SI Vérifier Toutes SI Vérifier MontageCorrectement Sont Courroies LES PA LA DE Tracteur LE Retirer PourConnaître pour mentnetionfonc tionsec la DesmanCom des fonction la et mentceplalem Fig la Voir Batterie LA VérifierTionrecdi DE Volant LE Fixer DU Tracteur LE Sortir PourPour Exigés Outils LES Carton LE DeballerMontar SIN Piezas Entreposage Montage SommaireUtilisation Client DU Responsabilités’utilisation pour Conseils Général EntretienTracteurs des sécurité toute ’ESSENCE DE Sûre ManipulationLES Dans Fonctionnement PentesTracteurs des sécurité toute en l’utilisation pour Conseils AUX Imprimé Avertissement
Top Page Image Contents