Poulan PRGT2046A owner manual KEY Part NO. NO. Description

Page 37

REPAIR PARTS

TRACTOR - - MODEL NUMBER PRGT2046A

STEERING ASSEMBLY

KEY PART

NO. NO. DESCRIPTION

1159944X428 Wheel, Steering

2137094 Axle Asm., Front

3

6855M

Fitting, Grease

4161849 Spindle Asm, LH

5161848 Spindle Asm., RH

6

6266H

Bearing, Race Thrust Harden

7121748X Washer 25/32 x 1-5/8 x 16 Ga.

812000029 Ring, Klip #T5304-75

9

121232X

Cap, Spindle

1074781044 Bolt, Fin Hex 5/8-11 x 2-3/4

11136518 Spacer, Brg. Axle Front

1273901000 Nut, Lock Flange 5/8-11 Unc

13121749X Washer 25/32 x 1-1/4 x 16 Ga.

1410040600 Washer, Lock Hvy Hlcl Spr 3/8

15	7810H	Nut Lock Center 3/8-24 Unf
16	145103	Shaft Asm., Steering
17	137347	Rod Tie Service

18137155 Draglink, Ball Joint Solid Vgt

19156011 Support Asm., Steering Vgt

20163887X428 Boot Steering Stealth GTYT

21	159945	Adapter, Wheel Steering
22	155105	Bushing, Strg.
23	152927	Screw

2574780616 Bolt, Fin Hex 3/8-16 x 1 Gr. 5

26159946X428 Insert Cap Strg WH

27

3366R

Bearing, Col. Strg.

2817000612 Screw Hexwsh thdr 3/8-16 x 3/4

29104239X Bearing, Flange

31

138136

Bushing, Nyliner Snap

3219111610 Washer 11/32 x 1 x 10 Ga.

3310040500 Washer, Lock Hvy Hlcl Spr 5/16

3474780512 Bolt, Hex Hd 5/16-18 x 3/4

35	138059	Gear, Sector Steering
36	137156	Tie Rod

3773360600 Jam Nut RH Thread

38109850X Joint Asm. Ball RH Thread

3973700600 Nut Hex Jam 3/8-24 LH Thread

40109851X Joint Asm. Ball LH Thread

41155246 Bracket Switch Interlock Vgt 97

4217490508 Screw Thdrol 5/16-18 x 1/2 Tyt

44160135X428 Extension Steering

4519132411 Washer 13/32 x 1-1/2 x 11 Ga.

NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm

37

Image 37

Contents PRGT2046A IV. Service Safety RulesGeneral Operation II. Slope OperationSafe Operation Practices for Ride-On Mowers Safety RulesTable of Contents Contents of Hardware Pack Tools Required for Assembly AssemblyHOW to SET UP Your Tractor To Remove Tractor from CartonAssemble Gauge Wheels to Mower Deck See Fig Install Seat See FigRemove banding holding deflector shield up against tractor Install Mulcher Plate See Fig To SET UP Your Mower for Mulching See FigInstall Mower and Drive Belt See Fig Install mulcher plate if previously removedCheck Mower Levelness Check Tire PressureCheck for Proper Position of ALL Belts Check Brake SystemChecklist Operation Know Your Tractor Height Adjustment Knob Used to adjust the mower heightTo Adjust Mower Cutting Height HOW to USE Your TractorBefore Starting the Engine To Start Engine See Fig Mowing TipsMulching Mowing Tips Customer Responsibilities Before Service DatesGeneral Recommendations Before Each USETractor Engine Clean AIR ScreenBelts Transaxle CoolingClean AIR INTAKE/COOLING Areas CleaningEngine OIL Filter MufflerTo Install Mower Service and AdjustmentsTo Level Mower Housing TractorTo Replace Mower Drive Belt Recheck side-to-side adjustmentTo Replace Mower Blade Drive Belt See Fig To Adjust Brake See Fig To Adjust Attachment Clutch See FigBelt Installation To Replace Motion Drive Belt See FigFront Wheel TOE-IN Adjustment To Adjust Steering Wheel AlignmentFront Wheel Camber To Remove Wheel for RepairsInterlocks and Relays To Replace Headlight BulbTo Replace Fuse To Adjust Carburetor To Remove Hood and Grill Assembly See FigTo Adjust Throttle Control Cable See Fig To Adjust Choke Control See FigOther StorageFuel System Engine OILProblem Cause Correction Troubleshooting PointsOFF Tractor - Model Number PRGT2046A SchematicElectrical KEY Part Description Chassis and Enclosures Repair Parts Ground Drive Wheel, Hub Assembly Steering Assembly KEY Part NO. NO. Description Engine Engine Briggs Model # 154 Seat AssemblyWheels & Tires Decals170563 Lift Assembly KEY Part NO. NO. Description Mower Deck KEY Part Description Transaxle Repair Parts Page Page Canada contact Limited WarrantySuggested Guide for Sighting Slopes for Safe Operation Parts and Service