RedMax EBZ5150RH manual Fuel, Gasoline Requirements, OIL Requirements, Warranty

Page 9

EBZ5150/RH

7. Fuel

FUEL

lines or fuel tank of the engine.

WARNING

• Gasoline is very flammable. Avoid smoking or bringing any

NOTE

• Failures caused by operating engines on gasoline with octane

flame or sparks near fuel. Make sure to stop the engine and

rating lower than 89 are not covered by the RedMax Two-

U

allow it cool before refueling the unit. Select outdoor bare

ground for fueling and move at least 10 ft (3 m) away from

the fueling point before starting the engine.

Stroke engine warranty.

WARNING

S

■GASOLINE REQUIREMENTS

• All 2-Stroke RedMax Products are powered by RedMax Professional-Commercial Duty, Hi-Performance, Hi-RPM, Air Cooled 2-Stroke engines.

RedMax – Hi-Performance 2-stroke engines produce higher HP outputs as compared to standard Home Owner Duty or Light Commercial Duty production engines offered by most manufacturers.

• Exhaust emission are controlled by the fundamental engine parameters and components (eq., carburation, ignition timing and port timing) without addition of any major hardware or the introduction of an inert material during combustion.

• The RedMax Engines are registered and certified with CARB (California Air Resources Board) and EPA (Environmental Protection Agency) to operate on CLEAN Mid-grade 89 octane or Premium, unleaded (lead-free) gasoline and RedMax Air- Cooled "Max Life", Synthetic blend Premium two-stroke engine oil mixed at 50:1 ratio.

• Unleaded gasoline is recommended to reduce the contamination of the air for the sake of your health and the environment.

• This Hi-Performance Air Cooled 2-stroke Engine requires the

use of Minimum 89 Octane [ R+M ] (Mid grade or Premium) 2

clean gasoline. Gasoline may contain maximum of 10% Ethanol (grain alcohol) or up to 15% MTBE (Methyl tertiary-butyl ether). Gasoline containing Methanol (Wood Alcohol) is NOT approved.

NOTE

•IF octane rating of the Mid Grade gasoline in your area is lower than 89 Octane use Premium Unleaded Gasoline. The majority of all 2-stroke engine manufacturers in the USA and Canada recommend using gasoline with 89 Octane or higher.

WARNING

•Gasoline with an octane rating lower than 89 will greatly increase the engines operating temperature. Low octane gasoline will cause detonation (knock) resulting in piston seizures and major internal engine components damage.

•Poor quality gasolines or oils may damage sealing rings, fuel

•Alternative Fuels (Not Gasoline)

Alternative fuels, such as E-15 (15% ethanol), E-20 (20% ethanol), E-85 (85% ethanol) are NOT classified as gasoline and are NOT approved for use in RedMax 2-stroke gasoline engines. Use of alternative fuels will cause major engine performance and durability problems such as: improper clutch engagements, overheating, vapor lock, power loss, lubrication deficiency, deterioration of fuel lines, gaskets and internal carburetor components, etc... Alternative fuels cause high moisture absorption into the fuel/oil mixture leading to oil and fuel separation.

■OIL REQUIREMENTS

•Use only RedMax "Max Life", Synthetic blend Premium Air- Cooled two-stroke engine oil or oil certified to ISO-L-EGD (ISO/CD1378) standard AND one that is JASO-FD registered. RedMax Air-Cooled "Max Life", Synthetic blend Premium two stroke engine oil and ISO-L-EGD (ISO/CD1378) AND JASO-FD oils are fully compatible with gasoline's containing 10% Ethanol. RedMax Air-Cooled "Max Life", Synthetic blend Premium two stroke engine oil and ISO-L-EGD (ISO/CD1378) AND JASO-FD oils are Universal and should be mixed at 50:1 ratio for all 2 stroke air cooled engines sold in the past regardless of mixing ratios specified in those manuals.

•If the oil is registered with JASO, the JASO Logo with FD and registration number will be displayed on the container. The highest JASO rating is "FD", which equals the ISO-L-EGD rating. Lower ratings are "FC", "FB", and "FA".

•Engine problems due to inadequate lubrication caused by failure to use ISO-L-EGD certified and JASO FD registered oil such as "MaxLife", RedMax Synthetic blend Premium 2-stroke oil WILL VOID THE REDMAX TWO-STROKE ENGINE

WARRANTY.

WARNING

•Do not use NMMA (National Marine Manufacturers Association), BIA (Boating Industry Association), and TCW (two cycle water cooled) oils designed for MoPeds or Outboard, water cooled Marine Engines. Do not use API (American Petroleum Institute), TC (Two Cycle) labeled oils. The API-TC

US-9

Page 8 Page 10
Image 9
Page 8 Page 10
Contents EBZ5150RH Contents Specifications Model EBZ5150/EBZ5150RH Dimensions L x W x H mmParts location Emission Control Symbols on the machineBefore use For safe operationAvoid noise problem Fuel safetyTransport StorageDisposal MaintenanceBlower Tubes Set upThrottle Lever Throttle Cable EBZ5150RHFuel WarrantyFuel Gasoline RequirementsHOW to MIX Fuel Recommended Mixing Ratio Gasoline 50 OIL For Your Engine LIFE, AvoidFueling the Unit Operation Starting EngineClose Adjusting Idle Speed F14 Adjusting the Shoulder StrapsStopping Engine EBZ5150 Emergency RemovalMaintenance AIR CleanerCleaning AIR Filter Procedures to be Performed After Every 100 Hours of USE Replacement Plug is a NGK CMR7HFuel Filter Spark PlugF26 Ignition Coil AIR GAP InspectionShoulder Strap Storage Troubleshooting guideDisposal Before Storing the BlowerOwners Warranty Responsibilities Manufacturers Warranty CoverageWarranty Commencement Date What is CoveredWhat is not Covered Emission Warranty Parts ListHOW to File a Claim Where to GET Warranty Service

EBZ5150, EBZ5150RH specifications

The RedMax EBZ5150RH and EBZ5150 are powerful backpack blowers designed for landscaping professionals and homeowners seeking efficient yard maintenance solutions. Both models are engineered with advanced technologies to deliver high performance while maintaining user comfort and convenience.

At the heart of the EBZ5150RH and EBZ5150 is a robust 50.2cc two-stroke engine, which provides exceptional airflow and efficient fuel consumption. This engine is specifically designed to deliver high-speed air output, making it ideal for moving leaves, debris, and grass clippings with ease. The impressive air volume of up to 511 CFM (cubic feet per minute) ensures that even the heaviest of tasks can be managed quickly and effectively.

One of the standout features of the EBZ5150RH model is the additional harness system that enhances user comfort during extended use. This professional-grade backpack blower comes with an ergonomic design that distributes weight evenly across the shoulders and back, reducing fatigue and strain. The padded shoulder straps and backrest further enhance comfort, allowing users to tackle large areas without discomfort.

Both versions are equipped with a popular cruise control feature, which allows operators to maintain a constant airflow speed without having to hold down the throttle. This feature is particularly beneficial during long periods of operation, leading to increased productivity and reduced hand fatigue. The easy-to-reach controls are intuitively located for user convenience.

The EBZ5150RH and EBZ5150 also incorporate advanced anti-vibration technology. This innovative system minimizes the vibrations transmitted to the user, promoting a more enjoyable experience and enhancing control, especially during extended use. This is crucial for professionals who rely on these machines daily.

Additionally, both blowers include a tool-less air filter cover, making maintenance hassle-free and allowing for quick cleaning and servicing. The durable construction of these blowers ensures longevity, appealing to both professional landscapers and residential users.

In conclusion, the RedMax EBZ5150RH and EBZ5150 backpack blowers are designed for maximum efficiency, user comfort, and durability. Their powerful engines, advanced ergonomic features, and ease of maintenance make them excellent choices for anyone looking to maintain their outdoor spaces effectively. Whether for professional landscaping or home use, these blowers deliver outstanding performance and reliability.
Top Page Image Contents