Fantom Vacuum VPW43H owner manual Trouble Shooting, Extension Cords

TROUBLE SHOOTING

SAFETY & WARNING INSTRUCTIONS

continued

PROBLEM		POSSIBLE REASON	POSSIBLE SOLUTION
PRESSURE			1.	Check plug, socket, fuses,
	1. Electrical socket is faulty or			breaker.
WASHER WILL
		breaker has tripped.	2.	Check that the voltage is
NOT START WHEN
	2.	Voltage is inadequate.		adequate.
THE ON/OFF
	3.	GFCI has tripped.	3.	Reset/Try another electrical
SWITCH IS IN THE
	4. Power cord is not plugged in.			outlet.
"ON" POSITION
			4.	Plug in power cord.
			1.	Remove and clean water
PUMP DOESN'T	1.	Water intake filter is clogged.		intake filter.
			2.	Tighten connections/bleed
REACH	2.	Pump is drawing air.
				system.
ADEQUATE	3.	Diameter of garden hose is
			3.	Replace with 3/4 inch
PRESSURE OR		too small.
				garden hose.
CAVITATES	4.	Water supply is restricted.
			4.	Check hose for kinks or
				leaks, open tap fully.
PRESSURE			1.	Turn unit and water supply
	1.	Excessive air in waterline and		off/Bleed system/Hold
WASHER HAS OR				trigger down. Allow water to
WILL NOT	2.	pump.		flow through the pump for
MAINTAIN		Water supply is restricted.	2.	30 seconds.
PRESSURE				Check hose for kinks or
				leaks, open tap fully.
PRESSURE	1.	Air intake is blocked.	1.	Clean the air intake vents.
WASHER MAKES
	2.	Water intake filter is dirty.	2.	Check & clean filter.
EXCESSIVE NOISE
MOTOR DOES
NOT RUN
CONTINUOUSLY
WHEN TRIGGER IS
SQUEEZED/
MOTOR BUZZES	1.	Net voltage is lower than	1.	Check that the voltage is
WHEN TURNED
		suggested.		adequate.
ON BUT DOES
NOT
START/MOTOR
STOPS RUNNING
WHILE UNIT IS IN
USE

WARNING

Do not use pressure that exceeds the operating pressure of any of the parts (hoses, fittings, etc.) in the pressurized system. Ensure that all equipment and accessories are rated to withstand the maximum working pressure of the unit.

WARNING

Explosion hazard.

•NEVER spray flammable liquids of use pressure washer in areas containing combustible dust, liquids or vapors.

•NEVER operate this machine in a closed building or in or near an explosive environment.

WARNING

Do not spray electrical apparatus or wiring.

•NEVER disconnect the high pressure discharge hose from the machine while the system is pressurized. To depressurize the machine, turn the power and water supply off, then press the gun trigger 2-3 times.

•NEVER permanently engage the trigger mechanism on the gun.

•NEVER operate the machine without all the components properly connected to the unit (handle, gun/lance assembly, nozzle, etc.).

WARNING

Equipment damage.

•ALWAYS turn water supply "ON" before turning the pressure washer "ON". Running pump dry causes serious damage.

•Do not operate the pressure washer with the inlet water screen removed. Keep screen clear of debris and sediment.

•NEVER operate pressure washer with broken or missing parts. Check equipment regularly and repair or replace worn or damaged parts immediately.

•Use only the nozzle supplied with this machine.

•Never leave the lance unattended while the machine is running.

•Never attempt to alter factory settings. Altering factory settings could damage the unit and will void the warranty.

•Always hold gun and lance firmly when starting and operating the machine.

•NEVER allow the unit to run with the trigger released (OFF) for more than one minute. Resulting heat buildup will damage pump.

•NEVER store the pressure washer outdoors or where it could freeze. The pump will be seriously damaged.

•Release trigger when changing from high to low pressure modes. Failure to do so could result to damage to the nozzle.

•This unit must always be used in the horizontal position.

CAUTION

Keep hose away from sharp objects. Bursting hose may cause injury. Examine hoses regularly and replace if damaged. Do not attempt to mend a damaged hose.

EXTENSION CORDS

DANGER

If using an extension cord, use only grounded, three wire extension cords that are in good condition. Use only extension cords that are intended for outdoor use. These extension cords are identified by a marking "Acceptable for use with outdoor appliances; store indoors while not in use." use only extension cords having an electrical rating not less than the product. Do not use damages extension cords. Examine extension cord before using and replace if damaged. Do not abuse extension cord and do not pull on the cord to disconnect. Keep cord away from heat and sharp edges. Always disconnect from the receptacle before disconnecting the product from the extension cord.

Note: Do not use 16 or 18 AWG extension cords on this product.

DANGER

Failure to follow these instructions can result in serious injury, including death.

WARNING

To reduce the risk of electrocution, keep all connections dry and off the ground. Do not touch the plug with wet hands.

Extension Cord	Allowable Length
	25'	50"
14 AWG	YES	NO
12 AWG	YES	YES

9 2