Country Home Products ROTO-HOGTM manual Tilling Tips, Cultivating Tips

Page 31

Tilling Tips

•In compacted soil or sod, or in food plot and sod busting applications, several passes may be necessary to till to a depth of seven (7) inches. For the first pass, just scratch the surface. The depth for each successive pass needs to be determined by individual site and soil conditions. If the machine stalls repeatedly, you should till slower or not as deep.

•Check the ground moisture. DO NOT till if you can make a ball of soil in your hand from the ground to be tilled; it is too wet. Create full tillage (depths up to 7") after entire area is dry.

•To obtain the most efficient tillage, operate the DR ROTO-HOG POWER TILLER Engine at full throttle at the slowest speed of your Tow Vehicle.

•When operating the machine for the first time, proceed slowly and carefully until you become familiar with the proper method of operating the machine.

•Soil conditions will determine how deep the machine can penetrate on the first pass.

•In damp soil, till only the top inch of seedbed. Allow tillage to dry for several hours in sunny and/or windy conditions.

•Listen to your DR ROTO-HOG POWER TILLER Engine. When the Engine RPM decreases or stalls (overloaded condition) raise the Tines for shallower tilling. If the Engine is lightly loaded, lower the Tines to increase the tilling depth.

•If the soil is extremely hard and dry, it may be desirable to “cross till” an area at a shallow depth first, then till the soil in the direction of planting rows on subsequent passes until the desired tillage is obtained.

•Where possible, we recommend that you till in a pattern similar to that shown in Figure 16.

1. Make the first pass.

NOTE: If you raise the tines at the end of a pass, use care to lower them back to the same depth. Tilling too deep on the first pass may cause the Tiller to stall or break Shear Pins.

2.Skip a space equal to the width of the machine.

3.Make the return pass.

4.Till the skipped areas.

Figure 16

Cultivating Tips

You can use the DR ROTO-HOG POWER TILLER for cultivating (Figure 17), which requires a minimum of two (2) inches of soil penetration.

•Set the tines so they will penetrate the soil to a depth of two (2) to three (3) inches.

•Run the DR ROTO-HOG POWER TILLER Engine at Full Throttle.

Figure 17

 

CALL TOLL FREE 1-800-DR-OWNER

27

Page 30 Page 32
Image 31
Page 30 Page 32
Contents DR ROTO-HOG Power Tiller Safety & Operating Instructions Meigs Road Vergennes, VT Toll-Free phone 1-800-DR-OWNER Fax Table of Contents Parts LISTS, Schematic Diagrams and Warranty Conventions used in this manual Introducing the DR ROTO-HOG Power TillerDR ROTO-HOG Power Tiller Specification Sheet Labels General Safety RulesDR ROTO-HOG Power Tiller Protecting Yourself and Those Around You Slope Operation Safety for ChildrenSafety with Gasoline-Powered Machines General Safety Additional Information and Potential Changes DR ROTO-HOG Power Tiller DR-OWNER Setting UP Your DR ROTO-HOG Power TillerDR ROTO-HOG Power Tiller Controls and Features Tool Needed Unpacking and Assembling the MachineOpening the Shipping Carton Parts Supplied on Shipping PalletFuses Axle Hold Down Brackets About the Battery Charging the BatteryExtra Wire Call TOLL-FREE 1-800-DR-OWNER Capacities Adding the Engine Oil and GasolineDrain Attaching the DR ROTO-HOG Power Tiller Control Box Connecting the DR ROTO-HOG Power Tiller to your Tow VehicleOperator Controls Operating Your DR ROTO-HOG Power TillerManual Starting Before Starting the EngineStopping the Engine Electric StartingOperating Safety Understanding the Control Box Gardens Operating ProceduresFood Plot Installation and Sod Busting Operating ParametersCultivating Tips Tilling TipsHandling and Transporting Slopes and Uneven TerrainRegular Maintenance Checklist Maintaining the DR ROTO-HOG Power TillerBefore Each Every Supplies Needed LubricationTines Shaft Tools & Supplies Recommended Removing and Replacing the Engine OilStore an unused Battery in a dry area that does not freeze Battery CareRecycling a Used Battery Disposing of the Battery ResponsiblyTools and Supplies Needed Removing and Replacing the V-BeltTine Operation Check Tine Shear PinsEnd of Season and Storage Troubleshooting Table TroubleshootingEngine will not start using Electric- Start Excessive bounce and difficult handling Parts List Main Assembly Parts LISTS, Schematic Diagrams and WarrantyPart# Description Schematic Diagram Main Assembly Ref# Part# Description Parts List -Tine Drive Transmission AssemblySchematic Diagram Tine Drive Transmission Assembly Part# Parts List Axle AssemblySchematic Diagram Axle Assembly Wiring Diagram Manual Start model Wiring Diagram Electric-Start model DR ROTO-HOG Power Tiller DR ROTO-HOGPOWER Tiller Quick Tilling Tips Daily Checklist for the DR ROTO-HOG Power Tiller

ROTO-HOGTM specifications

The Country Home Products ROTO-HOG™ is a revolutionary tool designed to simplify the process of garden tilling. This innovative rototiller combines power, efficiency, and user-friendly features to make it an essential addition to any gardener's toolkit.

One of the standout features of the ROTO-HOG™ is its lightweight and compact design, which allows for easy maneuverability in tight spaces. Whether you’re working in raised beds or narrow rows, the ROTO-HOG™ makes it effortless to till soil without causing damage to existing plants.

At the heart of the ROTO-HOG™ is its powerful engine, which provides a robust performance to tackle even the toughest soil. The engine features a high torque output, allowing it to penetrate hard, compacted earth with ease. This power ensures that the tiller can break up soil efficiently, promoting better aeration and nutrient absorption for healthier plant growth.

The advanced tilling technology in the ROTO-HOG™ includes adjustable tines that can be easily swapped out to suit different soil types and tilling depths. This versatility allows users to customize their tilling experience to match the requirements of their garden. The tines are designed to be self-sharpening, which means they maintain their effectiveness over time, reducing the need for frequent replacements.

Another significant characteristic of the ROTO-HOG™ is its ergonomic design. The handle is adjustable and cushioned, providing a comfortable grip that reduces strain during extended use. The tiller is also designed with safety features such as a safety shut-off switch, ensuring that users can operate the machine with confidence.

Ease of maintenance is another aspect that sets the ROTO-HOG™ apart. Its open design allows for straightforward access to essential components, making routine checks and servicing hassle-free. The enclosed engine compartment protects vital components from dirt and debris, contributing to the tool's longevity.

In summary, the Country Home Products ROTO-HOG™ is a cutting-edge rototiller that incorporates powerful technology, ergonomic design, and user-friendly features. Its compact size and advanced tilling capabilities make it an ideal choice for both novice gardeners and experienced horticulturists. With the ROTO-HOG™, achieving a healthy and thriving garden has never been easier.
Top Page Image Contents