CONNECTING PROCEDURE FOR RAISING OR SUSPENDING GENERATORS EQUIPPED WITH LIFT RINGS
Failure to properly connect lifting cables, chains, or straps can cause property damage, serious injury or death, and
void the manufacturer's warranty.
Always use cables, chains, or straps rated at 2000 lbs. working load or more to raise or suspend generator.
Never operate generator while suspended. This could cause property damage, serious injury or death.
1.Route cable, chain, or strap through both lift rings as shown. ALWAYS use both lift rings when raising or suspending generator.
NOTE: Make sure the generator is in a level position before raising or suspend- ing to prevent damage.
Lift Ring
Lift Ring
MAINTENANCE
CUSTOMER RESPONSIBILITIES TABLE
| Before | Every 25 | Every 50 | Every 100 |
| each | Hours of | Hours of | Hours of |
MAINTENANCE TASK | use | Every | Every | Every |
| Season | Season | Season | |
|
| |||
|
|
|
|
|
Check oil level | X | See Note 2 |
|
|
|
|
|
|
|
Change oil |
|
| See Note 1 |
|
|
|
|
|
|
Clean Air Filter Assembly |
| X |
|
|
|
|
|
|
|
Check Spark Plug |
| X |
| X |
Prepare Unit for Storage | Prepare | unit for storage if it is to remain | ||
| idle for more than 30 days. |
| ||
Note 1: Change oil after first two (2) operating hours and every 50 operating hours thereafter, more often if operated in extreme dusty or dirty conditions.
Note 2: Check oil after 5 hours of operation.
GENERAL RECOMMENDATIONS
The warranty of the generator does not cover items that have been subjected to operator abuse or negligence. To receive full value from the warranty, operator must maintain the generator as instructed in this manual.
ENGINE MAINTENANCE
Refer to the Engine Operator's manual for service and maintenance of the engine.
15- ENG | D26563 |