Powermate PMC401853 manual Fuel Tank Venting, Spark Arrester Muffler, Engine Maintenance Schedule

Page 3

FUEL TANK VENTING

 

LIMITED WARRANTY

 

 

 

CAUTION: Keep fuel tank area free of all debris, water, and ice. Do not block vent. “Tank must breathe.”

SPARK ARRESTER MUFFLER

This engine is equipped with a U.S. Forest Service approved spark arrest muffler. It should periodically be cleaned to prevent the screen from becoming clogged, which could hamper engine performance.

To clean, remove the muffler shield. Remove the four screws and pull the plate with the screen attached. Clean off any particles with a brush and reinstall. Be sure gasket is in place.

ENGINE MAINTENANCE SCHEDULE

Check engine oil . . . . . . . . . . . . . . . . . . . . . . Before each use Change engine oil . . . . . . . . . . . . After first 20 hours and then every 50 hours of operation Clean air filter. . . . . . . . . . . . . . . . Every 50 hours of operation

Clean spark plug . . . . . . . . . . . . Every 100 hours of operation Clean spark arrestor . . . . . . . . . . Every 50 hours of operation

Oil Type. Use new good quality oil such as SC, SD, and SE grades. The oil to be used depends upon the temperature at which the engine is operated:

Summer: (temperatures of over 40 degrees F/10 degrees

C) SAE 30 or SAE 10W-30, SAE 10W-40

Winter: (temperatures of below 40 degrees F/10 degrees C) SAE 20 or SAE 10W-30

Warranty Coverage: Powermate Corporation (the Company) warrants to the original retail customer in North America that it will repair or replace, free of charge, any parts found by the Company or its authorized service representative to be defective in material or workmanship. This warranty covers the cost of replacement parts and labor for defects in material or workmanship.

Not Covered:

·Transportation charges for sending the product to the Company or its authorized service representative for warranty service, or for shipping repaired or replacement products back to the customer; these charges must be borne by the customer.

·Engine is covered exclusively by a separate warranty from the engine manufacturer, included with the engine Manual.

·Damages caused by abuse or accident, and the effects of corrosion, erosion and normal wear and tear.

·Warranty is voided if the customer fails to install, maintain and operate the product in accordance with the instructions and recommendations of the Company set forth in the owner's manual, or if the product is used as rental equipment.

·The Company will not pay for repairs or adjustments to the product, or for any costs or labor, performed without the Company's prior authorization.

Warranty Period: Two (2) years from the date of purchase on products used solely for consumer applications; if a product is used for business or commercial applications, the warranty period will be limited to one (1) year from the date of purchase. For warranty service, the customer must provide dated proof of purchase and must notify the Company within the warranty period.

For warranty service: Call toll free 800-445-1805, or write to Powermate Corporation, Product Services, 4970 Airport Road, P. O. Box 6001, Kearney, NE 68848.

EXCLUSIONS AND LIMITATIONS: THE COMPANY MAKES NO OTHER WARRANTY OF ANY KIND, EXPRESS OR IMPLIED. IMPLIED WARRANTIES, INCLUDING WARRANTIES OF MERCHANTABILITY AND OF FITNESS FOR A PARTICULAR PURPOSE, ARE HEREBY DISCLAIMED. THE WARRANTY SERVICE DESCRIBED ABOVE IS THE EXCLUSIVE REMEDY UNDER THIS WARRANTY; LIABILITY FOR INCIDENTAL AND CONSEQUENTIAL DAMAGES IS EXCLUDED TO THE EXTENT PERMITTED BY LAW.

This warranty gives you specific legal rights, and you may also have other rights which vary from state to state. Some states do not allow a disclaimer of implied warranties, or the exclusion or limitation of incidental and consequential damages, so the above disclaimers and exclusions may not apply to you.

 

 

 

English

3

 

 

 

Page 2 Page 4
Image 3
Page 2 Page 4
Contents PMC401853 Circuit Breaker Major Generator FeaturesEndbell 120 V, 15 Ampere Duplex ReceptacleNot Covered Engine Maintenance ScheduleFuel Tank Venting Spark Arrester MufflerWarranted Parts Disjoncteurs Caractéristiques Principales DU Groupe ElectrogeneCOVRE-ENROULEMENT Prise double de 120 V, 15 aCe qui nest pas couvert LE Silencieux PARE-ETINCELLESLE Plan Dentretien DE Moteur Garantie LimitéeCouverture DE Garantie DU Fabricant Caracteristicas Principales DEL Generador Receptáculo dúplex de 120 voltios, 15 amperesInterruptor Garantia Limitada Silenciador DEL Arrestor DE ChispasEL Horario DE LA Mantenimiento DEL Motor Cobertura DE LA Garantía DEL Fabricante PMC401853 Parts Drawing / Schema DES Pièces / Diagrama DE PiezasParts List / Liste DES Pièces / Lista DE Piezas Page Page Page Airport Road Box Kearney, NE Fax

PMC401853 specifications

The Powermate PMC401853 is a versatile and high-performing generator designed to meet a wide range of power needs for both residential and commercial applications. This dependable unit is equipped with advanced technology and features that enhance its performance and usability.

One of the standout characteristics of the Powermate PMC401853 is its powerful engine. Featuring a robust OHV engine, this generator delivers reliable performance and efficiency, allowing users to power essential appliances and equipment during outages or when working in remote locations. With a starting wattage of 4,850 watts and a running wattage of 3,850 watts, it is capable of handling a variety of devices, from household refrigerators to power tools.

The unit is also designed with user-friendliness in mind. It showcases a control panel that is easy to navigate, featuring multiple outlets, including two 120V household outlets, one 12V DC outlet, and a 30A RV outlet. This selection allows users to connect numerous devices simultaneously, making it ideal for camping trips, outdoor events, or emergency situations.

Another essential feature of the Powermate PMC401853 is its portable design. It is built with a sturdy frame and includes never-flat wheels, making it easy to transport from one location to another. Its foldable handles enhance portability and storage convenience, allowing users to easily manage the unit without taking up significant space when not in use.

Safety is a priority with the PMC401853. It is equipped with a low-oil shutdown feature that automatically turns off the engine when oil levels are too low, preventing potential engine damage. Additionally, the generator features a circuit breaker that protects against overloads, ensuring safe operation during use.

Moreover, the Powermate PMC401853 operates at a relatively low noise level, making it suitable for use in residential areas without causing disturbances. This noise reduction technology allows users to enjoy reliable power without the irritation of excessive sound.

In summary, the Powermate PMC401853 is an excellent generator that combines power, portability, and user-friendly features. Its robust engine, variety of outlets, safety features, and relatively quiet operation make it a top choice for anyone in need of reliable backup power or portable electricity solutions.
Top Page Image Contents