Multiquip JTNS20HTCSL, JTNSW20HTCSL manual Harness Assy

Page 56

HARNESS ASSY.

P2

CONNECT TO

RIGHT FRONT LIGHT

P3

CONNECT TO

LEFT FRONT LIGHT

P2

CONNECT TO

LIGHT KIT HARNESS

J1

CONNECT TO

SPRAY KIT HARNESS

J1

CONNECT TO

SPRAY SWITCH

J3

CONNECT TO

SPRAY PUMP

	T1
CONNECT TO
ENGINE HARNESS	T2

T2

30A

FUSE OUT

	CONNECT TO
	LIGHT SWITCH
	T1	T2	CONNECT TO
	T1	T2	REAR LIGHT
			REAR LIGHT
			P1

LIGHT KIT

1 HARNESS

J1

CTRL. BOX	CTRL. BOX	RELAY	VOLTAGE
GND.	GND.	COIL	REGULATOR
T4	T3	T2	T1

	MAIN
2	PANEL HARNESS
	PANEL HARNESS
	P1

T5 T6

ENGINE 30A

GND. FUSE IN

	3	SPRAY KIT
	3	HARNESS
		HARNESS

J2

4	CONNECT TO
	SEAT SWITCH
	P1
5	CONNECT TO
	STARTER SOLENOID
	T1

page 56 — JTNS/SW20H RIDE-ON POWER TROWEL• parts manual — rev. #1 (11/08/13)

Image 56

Contents JTNS20HTCSL JTNSW20HTCSL JTNS/SW20H Ride-On Power Trowel Table of ContentsPage Explanation of Code in Remarks Column Xxxxx only Not Used onSuggested Spare Parts Nameplate and decals DECAL, Lubrication Point DECAL, Pitch RHDECAL, Protective Clothing DECAL, Pitch LHSteering ASSY. LEFT-SIDE BEARING, Housing WASHER, LOCK, 3/8 MEDROD END, 3/8-24 Female RH JtnsSee Spray Assembly Steering ASSY. RIGHT-SIDE Jtns pivot assy ARM, Pivot RH TUBE, PivotRocker Block TUBE, Control PivotJtnsw LEFT-side pivot assy SCREW, SHS M6 X1.0 X 20MM TUBE, Pivot LHPLATE, Gearbox Adaptor Jtnsw RIGHT-side pivot assy Part Name SHIM, SteelJtns gearbox assy. LEFT-SIDE Pipe Plug 3/8 Snap RING, EXTERNAL, 1-1/8 DIARing COVER, Gearbox OutputJtns gearbox assy. right-side 15 1Worm Counter Shaft RS GEAR, WORM, COMPOSITE, RHWASHER, Lock 5/16 EXT. Tooth Jtnsw gearbox assy. LEFT-SIDE Apply Loctite White #572 Apply Loctite Blue #242WASHER, Lock 1/4 MED COVER, Gear BOXSight Glass FLANGE, Input ShaftJtnsw gearbox assy. RIGHT-SIDE 20# 24157 Pitch Control Tower Assy PIN, Adjustment HOUSING, Pitch ControlCOVER, Pitch Control Housing SPRING, Handle Balance CoilPitch Control Tower Assy WASHER, M8 Split Lock Knob W/ BoltJTNS/JTNSW LEVER, Trowel ADJPitch Control Drive Cable Assy Drive CABLE, Pitch Control GEAR, Pitch ControlCLAMP, Pitch Cable Fuel Tank Assy WASHER, Flat SAE 1/4 TIE, Cable TY-RAP BlackCLAMP, Stepless EAR Fuel TankDrive Assy Boot ASM., C.V. Joint GASKET, C.V. Joint BootWASHER, Lock 5/16 MED Shaft Drive BearingEngine Mounting and Clutch Assy Weight SPRING, 4 Clutch WEIGHT, 4 Posi Grip ClutchStem Clutch Assembly WASHER, Flat SAE 5/16Engine Components NUT, Tool BOX Setting GROMMET, AIR CleanerAIR FILTER, Outer MufflerSpider ASSY. Left Wear Ring Flange BearingLower Wear Plate BUSHING, Trowel Small ARMSpider ASSY. Right BUSHING,TROWEL Small ARM SPRING, R.S. ARM ReturnSCREW, Retaining LEVER, TROWEL, LH, GreenSeat Frame Assy Connector BODY, Male Includes Items W/$Seat TERMINAL, FemaleFoot Pedal Assy STOPPER, Wire CASING, Throttle WirePIN, Accelerator Pedal NUT, NylocBattery Assy Battery BOX BATTERY,WET, 36B20BRACKET, Battery Hold Down BOLT, Battery BOXSpray Tank Assy 10 8HOLDER, Spray Switch NOZZLE, SPRAY, 1/4-19 PT MaleFITTING, PF 1/4- 10MM DIA CLAMP, Hose WORM, 12-15 MMLights Assy BOOT, Toggle Switch CLAMP, 1-3/4 MufflerLIGHT, Rectangular NUT, Nyloc M8Front Panel Assy WASHER, FENDER, 1.5OD X 3/8 ID NUT, PLATE, #10-32, CLIP-ONControl Panel SHEET, Trim BackingHarness Assy Seat Switch Harness Power Panel HarnessLight KIT Harness Main Panel HarnessMover and Lift Handle Assy Hand Grip Upper HandleSnap PIN ClipTerms and Conditions of Sale Parts FReIgHT pOLICYPage HERE’S HOW to GET Help