Char-Broil 463243911 For Safe Use of Your Grill and to Avoid Serious Injury, Ignitor Lighting

Page 7

WARNING

For Safe Use of Your Grill and to Avoid Serious Injury:

•Do not let children operate or play near grill.

•Keep grill area clear and free from materials that burn.

•Do not block holes in sides or back of grill.

•Check burner flames regularly.

•Use grill only in well-ventilated space. NEVER use in enclosed space such as carport, garage, porch, covered patio, or under an overhead structure of any kind.

•Do not use charcoal or ceramic briquets in a gas grill. (Unless briquets are supplied with your grill.)

•Use grill at least 3 ft. from any wall or surface. Maintain 10 ft. clearance to objects that can catch fire or sources of ignition such as pilot lights on water heaters, live electrical appliances, etc.

•Apartment Dwellers:

Check with management to learn the requirements and fire codes for using an LP gas grill in your apartment complex. If allowed, use outside on the ground floor with a three (3) foot clearance from walls or rails. Do not use on or under balconies.

•NEVER attempt to light burner with lid closed. A buildup of non-ignited gas inside a closed grill is hazardous.

•Never operate grill with LP cylinder out of correct position specified in assembly instructions.

•Always close LP cylinder valve and remove coupling nut before moving LP cylinder from specified operation position.

Safety Tips

sBefore opening LP cylinder valve, check the coupling nut for tightness.

sWhen grill is not in use, turn off all control knobs and LP cylinder valve.

sNever move grill while in operation or still hot. Uselong-handled barbecue utensils and oven mitts to avoid

burns and splatters.

sMaximum load for sideburner and side shelf is 10 lbs.

greaseThe tray must be inserted into grill and emptied after each use. Do not remove grease tray until grill has completely cooled.

sClean grill often, preferably after each cookout. If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

sIf you notice grease or other hot material dripping from grill onto valve, hose or regulator, turn off gas supply at once. Determine the cause, correct it, then clean and inspect valve, hose and regulator before continuing. Perform a leak test.

sKeep ventilation openings in cylinder enclosure (grill cart) free and clear of debris.

sDo not store objects or materials inside the grill cart enclosure that would block the flow of combustion air to the underside of either the control panel or the firebox bowl.

sThe regulator may make a humming or whistling noise during operation. This will not affect safety or use of grill.

sIf you have a grill problem see the "Troubleshooting Section". sIf the regulator frosts, turn off grill and LP cylinder valve

immediately. This indicates a problem with the cylinder and it should not be used on any product. Return to supplier!

CAUTION

•Putting out grease fires by closing the lid is not possible. Grills are well ventilated for safety reasons.

•Do not use water on a grease fire. Personal injury may result. If a grease fire develops, turn knobs and LP cylinder off.

•Do not leave grill unattended while preheating or burning off food residue on HI. If grill has not been regularly cleaned, a grease fire can occur that may damage the product.

Ignitor Lighting

sDo not lean over grill while lighting.

1.Turn OFF gas burner control valves.

2.Turn ON gas at LP cylinder.

3.Open lid during lighting.

4.To ignite, push and turn ignition burner knob to HI.

5. .Push and hold ELECTRONIC IGNITION button until the burner lights.

6.If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure.

7.To ignite remaining burners, turn knob to the HI position starting with the burners closest to IGNITION BURNERS first. If ignitor does not work, follow match lighting instructions.

Lighting instructions are continued on the next page

7

Page 6 Page 8
Image 7
Page 6 Page 8
Contents Date Purchased Estimated assembly time 30-40 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Open lid during lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting SDo not lean over grill while lightingBurner Flame Check General Grill CleaningSideburner Ignitor Lighting Sideburner Match LightingTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Very Important Burner tubes must reengage valveItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListParts Diagram Front AssemblyUpper back panel Temperature gauge stem Foldable side shelf Right side shelf Back of main control panel Grease tray opening Wire Flame tamers Grease tray Cylinder screw at rear of cart Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA

463243911 specifications

The Char-Broil 463243911 is an innovative gas grill designed for both amateur and seasoned grill masters. This versatile outdoor cooking appliance combines advanced technology, powerful performance, and user-friendly features, making it a popular choice among barbecue enthusiasts.

One of the standout features of the Char-Broil 463243911 is its TRU-Infrared cooking technology. This patented system ensures even heat distribution across the grilling surface, minimizing hot and cold spots. By using infrared heat, the grill enhances flavor retention while reducing flare-ups, providing juicier and more perfectly cooked foods. As a result, users can achieve a consistently high-quality grilling experience, whether they are searing steaks, roasting vegetables, or barbecuing chicken.

This grill boasts a total cooking area of 450 square inches, which includes a primary grilling area of 350 square inches and a porcelain-coated warming rack offering an additional 100 square inches. This ample space allows users to prepare meals for family gatherings or parties effortlessly. The stainless-steel burners provide reliable heating with a total output of 36,000 BTUs, ensuring plenty of power for high-temperature grilling.

Durability is another hallmark of the Char-Broil 463243911. It's constructed with high-quality materials, including stainless steel and porcelain-coated surfaces, which resist rust and weathering. This grill is built to withstand outdoor elements, ensuring long-lasting use and an attractive look for years to come.

The grill's design is also focused on convenience. The integrated electronic igniter allows for quick and hassle-free startup. Additionally, the grill comes equipped with side shelves that provide ample prep space, as well as tool hooks for easy access to utensils. The built-in grease tray with a removable design simplifies cleanup, allowing users to focus more on cooking and less on maintenance.

Furthermore, the Char-Broil 463243911 features a compact cart design with wheels, providing portability while maintaining stability during use. This thoughtful engineering makes it easy to move the grill in and out of storage as needed.

In summary, the Char-Broil 463243911 is a robust gas grill that integrates effective cooking technology, a generous cooking area, and a user-friendly design, making it ideal for anyone looking to elevate their outdoor cooking experience. With its innovative features and durable construction, this grill is poised to deliver delicious results for years to come.
Top Page Image Contents