Char-Broil 463247310 manual Rear of Shelf

Page 17

7

Insert flange on right side shelf into side shelf brackets on side of firebox, shown A.

Attach rear of shelf using one 1/4-20x3/4”screw, 7mm lock washer, 7mm flat washer and 1/4”nut in upper hole; using one 1/4-20x1½”screw, 7mm lock washer and 7mm flat washer in lower hole, shown B/C.

Attach front of shelf and fascia using two 1/4-20x3/4”screws, 7mm flat washers, 7mm lock washers and1/4”nuts, and one #8x3/8” self-tapping screw with large washer, shown C/D/E.

A

					7mm lock			C
	B	Rear of Shelf			7mm lock
					washer	7mm flat


					1/4”nut	washer
					1/4”nut
			1/4-20x3/4” screw
						7mm lock
						washer
			1/4-20x1½” screw
		7mm flat	7mm lock
		washer	washer				7mm flat
		washer
						1/4”nut
						1/4”nut	washer

DBack of main control panel

Igniter Switch

1/4-20x3/4” screw

Note: Insert this screw from the back of main control panel

E

1/4-20x3/4” screw

#8x3/8” tapping screw

large flat washer

1/4”nut

7mm lock washer

7mm flat washer

17

Image 17

Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UL listed Overfill ProtectionLP Cylinder Leak Test For your safetyUseDo not household cleaning agents. Damage to gas Turn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator Main Burner Lighting Instructions For Safe Use of Your Grill and to Avoid Serious InjurySideburner Match Lighting Side Burner Lighting InstructionsBurner Flame Check Ignitor CheckCooking surfaces If a bristle brush is used to clean any General Grill CleaningStoring Your Grill SurfacesTurn gas off at control knobs and LP cylinder Cleaning the Burner AssemblyItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListNot Pictured Parts Diagram Front AssemblyFixed caster Locking caster Bottom shelf RearGrill head Regulator hose Lower back panel Rear of Shelf Screws and Washers removed from valve bracket Back of main control panel Now you may fully tighten lower screws on upper back panelFront of Shelf Holes on fascia to Sideburner lid Front brace Page Wire Frontbrace Right door Cooking grate Cylinder screw at rear of cart Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionWarranty Registration Department Box Columbus, GA