Char-Broil 463270610 For Safe Use of Your Grill and to Avoid Serious Injury, Ignitor Lighting

Page 7

WARNING

For Safe Use of Your Grill and to Avoid Serious Injury:

•Do not let children operate or play near grill.

•Keep grill area clear and free from materials that burn.

•Do not block holes in sides or back of grill.

•Check burner flames regularly.

•Use grill only in well-ventilated space. NEVER use in enclosed space such as carport, garage, porch, covered patio, or under an overhead structure of any kind.

•Do not use charcoal or ceramic briquets in a gas grill. (Unless briquets are supplied with your grill.)

•Use grill at least 3 ft. from any wall or surface. Maintain 10 ft. clearance to objects that can catch fire or sources of ignition such as pilot lights on water heaters, live electrical appliances, etc.

•Apartment Dwellers:

Check with management to learn the requirements and fire codes for using an LP gas grill in your apartment complex. If allowed, use outside on the ground floor with a three (3) foot clearance from walls or rails. Do not use on or under balconies.

•NEVER attempt to light burner with lid closed. A buildup of non-ignited gas inside a closed grill is hazardous.

•Never operate grill with LP cylinder out of correct position specified in assembly instructions.

•Always close LP cylinder valve and remove coupling nut before moving LP cylinder from specified operation position.

Safety Tips

sBefore opening LP cylinder valve, check the coupling nut for tightness.

sWhen grill is not in use, turn off all control knobs and LP cylinder valve.

sNever move grill while in operation or still hot. Uselong-handled barbecue utensils and oven mitts to avoid

burns and splatters.

sMaximum load for sideburner and side shelf is 10 lbs.

greaseThe tray must be inserted into grill and emptied after each use. Do not remove grease tray until grill has completely cooled.

sClean grill often, preferably after each cookout. If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

sIf you notice grease or other hot material dripping from grill onto valve, hose or regulator, turn off gas supply at once. Determine the cause, correct it, then clean and inspect valve, hose and regulator before continuing. Perform a leak test.

sKeep ventilation openings in cylinder enclosure (grill cart) free and clear of debris.

sDo not store objects or materials inside the grill cart enclosure that would block the flow of combustion air to the underside of either the control panel or the firebox bowl.

sThe regulator may make a humming or whistling noise during operation. This will not affect safety or use of grill.

sIf you have a grill problem see the "Troubleshooting Section". sIf the regulator frosts, turn off grill and LP cylinder valve

immediately. This indicates a problem with the cylinder and it should not be used on any product. Return to supplier!

CAUTION

•Putting out grease fires by closing the lid is not possible. Grills are well ventilated for safety reasons.

•Do not use water on a grease fire. Personal injury may result. If a grease fire develops, turn knobs and LP cylinder off.

•Do not leave grill unattended while preheating or burning off food residue on HI. If grill has not been regularly cleaned, a grease fire can occur that may damage the product.

Ignitor Lighting

sDo not lean over grill while lighting.

1.Turn OFF gas burner control valves.

2.Turn ON gas at LP cylinder.

3.Open lid during lighting.

4.To ignite, push and turn ignition burner knob to HI.

5. .Push and hold ELECTRONIC IGNITION button until the burner lights.

6.If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure.

7.To ignite remaining burners, turn knob to the HI position starting with the burners closest to IGNITION BURNERS first. If ignitor does not work, follow match lighting instructions.

Lighting instructions are continued on the next page

7

Page 6 Page 8
Image 7
Page 6 Page 8
Contents Product Guide This Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Open lid during lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting SDo not lean over grill while lightingBurner Flame Check General Grill CleaningSideburner Ignitor Lighting Sideburner Match LightingTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Very Important Burner tubes must reengage valveItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListParts Diagram Front AssemblyUpper back panel Temperature gauge stem Foldable side shelf Right side shelf Back of main control panel Grease tray opening Wire Flame tamers Grease tray Cylinder screw at rear of cart Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA

463270610 specifications

The Char-Broil 463270610 is an innovative and feature-rich gas grill that has gained popularity among outdoor cooking enthusiasts. Known for its reliability and performance, this grill offers a robust cooking platform that delivers delicious results.

One of the standout features of the Char-Broil 463270610 is its 4-burner design, which provides ample cooking space and flexibility. Each stainless steel burner produces a total of 40,000 BTUs, allowing for precise temperature control and even heat distribution across the cooking surface. This is particularly beneficial when grilling different types of food at the same time, as users can easily adjust the heat to suit each dish.

The cooking area is spacious, offering a 485 square inch main grill area along with an additional 190 square inch swing-away warming rack. This combination allows for a total of 675 square inches of cooking space, making it perfect for family gatherings or outdoor parties. The grate is made from porcelain-coated cast-iron, which not only provides excellent heat retention but also makes for easy cleaning.

Another significant feature is the built-in ignition system that ensures a quick and reliable startup. With just the push of a button, the grill ignites, eliminating the hassle of matches or lighter fluid. The lid-mounted temperature gauge is also a valuable addition, allowing users to monitor cooking temperatures without lifting the lid and losing heat.

The Char-Broil 463270610 is designed with durability in mind. It features a sturdy, all-steel frame that is complemented by a rust-resistant finish. The grill comes with side shelves that offer extra space for food preparation and utensils, enhancing convenience during the grilling experience. Additionally, the four caster wheels make it easy to move the grill around the yard or patio.

This gas grill also incorporates the TRU-Infrared cooking technology, which promotes even heat distribution and helps reduce flare-ups. This technology not only enhances cooking performance but also contributes to a moister cooking environment, ensuring that meats remain juicy and flavorful.

In summary, the Char-Broil 463270610 stands out as a versatile and well-engineered gas grill. With features like its powerful burners, ample cooking space, reliable ignition system, and innovative cooking technology, it offers a complete grilling experience for both novices and seasoned grill masters alike. This grill is an excellent investment for anyone looking to elevate their outdoor cooking game.
Top Page Image Contents