Char-Broil 463460712 manual Front, Assembly

Page 17

ASSEMBLY

1

Place bottom shelf upside down. Insert Caster Pin into the caster mounting plate to lock it in place, shown A.

Spin the caster clockwise into the threads on the bottom shelf until secure. Remove the Caster Pin and repeat for remaining

casters. Make sure the two locking casters are secured at the rear and the non-locking casters are secured at the front. After all 4 casters are secure remove the Caster Pin and save for future maintenance.

Fixed caster

Locking caster

A

Caster pin

Front

Bottom shelf

Rear

2	Attach side panels to bottom shelf using three 1/4-20x1/2”
	screws, 7mm lock washers, and 7mm flat washers per panel.

IMPORTANT: Panel with large hole must

Be on left side of bottom shelf.

Right side panel

Make sure side panels are pushed as far to the rear of bottom shelf as possible before fully tightening screws.

1/4-20x1/2” screw

7mm lock washer

7mm flat washer

Left side panel (with large hole)

Rear

17

Image 17

Contents Date Purchased Product GuideThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsFirst Time Use Temperature Convective Grills onlyLava Rock / Briquettes Pre-Heating Your GrillDirect Cooking Food SafetyIndirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures General Cleaning Why Clean?Routine Care Storing Your GrillLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UL listed Overfill ProtectionLP Cylinder Leak Test For your safetyUseDo not household cleaning agents. Damage to gas Turn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjurySDo not lean over grill while lighting Open lid during lightingSideburner Ignitor Lighting General Grill CleaningSideburner Match Lighting Burner Flame CheckStoring Your Grill Cleaning the Burner AssemblyVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinder All Parts Year from date of purchase Limited WarrantyKey Qty Description Parts ListPage Front AssemblyMagnet 5mm flat washers #10-24x1/2 screws 5mm lock washers #8-32x3/8 Machine screws Side shelf Supports Tube Valve Place sideburner cooking grate into holes in drip pan Place cooking grates into grill bottom Grease Cup Wire LP Cylinder Not included Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Mail to / Envíelo a