Char-Broil 463257111 For Safe Use of Your Grill and to Avoid Serious Injury, Ignitor Lighting

Page 7

WARNING

For Safe Use of Your Grill and to Avoid Serious Injury:

•Do not let children operate or play near grill.

•Keep grill area clear and free from materials that burn.

•Do not block holes in sides or back of grill.

•Check burner flames regularly.

•Use grill only in well-ventilated space. NEVER use in enclosed space such as carport, garage, porch, covered patio, or under an overhead structure of any kind.

•Do not use charcoal or ceramic briquets in a gas grill. (Unless briquets are supplied with your grill.)

•Use grill at least 3 ft. from any wall or surface. Maintain 10 ft. clearance to objects that can catch fire or sources of ignition such as pilot lights on water heaters, live electrical appliances, etc.

•Apartment Dwellers:

Check with management to learn the requirements and fire codes for using an LP gas grill in your apartment complex. If allowed, use outside on the ground floor with a three (3) foot clearance from walls or rails. Do not use on or under balconies.

•NEVER attempt to light burner with lid closed. A buildup of non-ignited gas inside a closed grill is hazardous.

•Never operate grill with LP cylinder out of correct position specified in assembly instructions.

•Always close LP cylinder valve and remove coupling nut before moving LP cylinder from specified operation position.

Safety Tips

sBefore opening LP cylinder valve, check the coupling nut for tightness.

sWhen grill is not in use, turn off all control knobs and LP cylinder valve.

sNever move grill while in operation or still hot. Uselong-handled barbecue utensils and oven mitts to avoid

burns and splatters.

sMaximum load for sideburner and side shelf is 10 lbs.

greaseThe tray must be inserted into grill and emptied after each use. Do not remove grease tray until grill has completely cooled.

sClean grill often, preferably after each cookout. If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

sIf you notice grease or other hot material dripping from grill onto valve, hose or regulator, turn off gas supply at once. Determine the cause, correct it, then clean and inspect valve, hose and regulator before continuing. Perform a leak test.

sKeep ventilation openings in cylinder enclosure (grill cart) free and clear of debris.

sDo not store objects or materials inside the grill cart enclosure that would block the flow of combustion air to the underside of either the control panel or the firebox bowl.

sThe regulator may make a humming or whistling noise during operation. This will not affect safety or use of grill.

sIf you have a grill problem see the "Troubleshooting Section". sIf the regulator frosts, turn off grill and LP cylinder valve

immediately. This indicates a problem with the cylinder and it should not be used on any product. Return to supplier!

CAUTION

•Putting out grease fires by closing the lid is not possible. Grills are well ventilated for safety reasons.

•Do not use water on a grease fire. Personal injury may result. If a grease fire develops, turn knobs and LP cylinder off.

•Do not leave grill unattended while preheating or burning off food residue on HI. If grill has not been regularly cleaned, a grease fire can occur that may damage the product.

Ignitor Lighting

sDo not lean over grill while lighting.

1.Turn OFF gas burner control valves.

2.Turn ON gas at LP cylinder.

3.Open lid during lighting.

4.To ignite, push and turn ignition burner knob to HI.

5. .Push and hold ELECTRONIC IGNITION button until the burner lights.

6.If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure.

7.To ignite remaining burners, turn knob to the HI position starting with the burners closest to IGNITION BURNERS first. If ignitor does not work, follow match lighting instructions.

Lighting instructions are continued on the next page

7

Page 6 Page 8
Image 7
Page 6 Page 8
Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Open lid during lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting SDo not lean over grill while lightingBurner Flame Check General Grill CleaningSideburner Ignitor Lighting Sideburner Match LightingTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Very Important Burner tubes must reengage valveItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListParts Diagram Front Assembly7mm flat washers on each side Upper back panel Now you may fully tighten lower screws on upper back panel Holes on fascia to Attach valve bracket Sideburner Ignitor Wire Rear Wire Warming rack Cooking grate Tank is attached. Failure to install cylinder Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA

463257111 specifications

The Char-Broil 463257111 is a robust and versatile gas grill that has gained popularity among both novice and experienced grillers. Designed with practicality and ease of use in mind, this grill features a variety of attributes that enhance the grilling experience, making it a worthy addition to any backyard setup.

One of the defining features of this gas grill is its high-quality construction. It boasts a durable stainless steel frame that not only ensures longevity but also provides resistance against rust and corrosion. The grill has a sleek appearance that complements any outdoor decor, though its practical design is just as significant as its aesthetics.

The Char-Broil 463257111 is equipped with four main burners, each providing 10,000 BTUs of heating power. This allows for a total cooking power of 40,000 BTUs, giving users ample heat for grilling various types of meat and vegetables. The burners are outfitted with electronic ignition systems for quick and reliable startups, allowing you to get grilling without the hassle of matches or lighters.

The cooking surface of the Char-Broil 463257111 is generous, providing 425 square inches of primary cooking space, along with an additional 150 square inches of warming rack. This ample cooking area is perfect for hosting gatherings or family barbecues, enabling users to cook enough food for several guests simultaneously.

One standout feature of this grill is its TRU-Infrared cooking technology. This innovative system promotes even heat distribution, ensuring that food cooks uniformly, preventing hotspots that can lead to uneven cooking. The infrared technology not only enhances flavor by sealing in juices, but it also reduces flare-ups, leading to a more controlled cooking environment.

Additionally, the grill features side shelves that offer extra prep space for condiments and tools, while the built-in thermometer allows for precise monitoring of cooking temperatures. This function is crucial for achieving the perfect cook on different types of meat.

Ease of maintenance is another characteristic of the Char-Broil 463257111. The grill is easy to clean, with removable grease trays simplifying the cleanup process after cooking, ensuring that you can spend more time enjoying your meals rather than cleaning.

In conclusion, the Char-Broil 463257111 is an exemplary gas grill that combines quality construction, powerful performance, and innovative technology. Whether you are an ardent grilling enthusiast or a casual cook, this grill provides everything you need for a successful outdoor cooking experience.
Top Page Image Contents