Sideburner Ignitor Lighting, Ignitor Check

WARNING

Turn controls and gas source or tank OFF when not in use.

CAUTION

If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury.

Main Burner Match-Lighting

Do not lean over grill while lighting.

1.Turn OFF all gas burner control valves.

2.Turn ON gas at LP cylinder.

3.Open lid during lighting.

4.Place match into match holder (hanging from side of cart). Light match, place into lighting hole on right or left side of firebox.

5.Push in and turn far right or far left knob to position. Be sure burner lights and stays lit.

6.If ignition does NOT occur in 5 seconds, turn the burner

control knob OFF, wait 5 minutes, and repeat the lighting procedure.

7.Light other burners by pushing knob in and turning to position. If your grill has two cooking zones, repeat steps 4

through 6 for the remaining section of the grill.

Warning:

Top cover must be open when side burner(s) is in operation.

NOTE: Your grill may NOT be equipped with a Sideburner!

Sideburner Ignitor Lighting

Do not lean over grill while lighting.

1.Turn OFF all gas burner control valves.

2.Turn ON gas at LP cylinder.

3.To ignite SIDEBURNER, open sideburner cover.

4.Turn sideburner knob to the position.

5.Push and hold ELECTRONIC IGNITOR button until the burner lights.

6.Once burner has ignited, turn knob to desired setting.

7.If sideburner does not light, turn knob to OFF, wait 5 minutes, then repeat lighting procedure.

Sideburner Match Lighting

Do not lean over grill while lighting.

1.Open lid during lighting. Turn ON gas at LP cylinder.

2.Place lit match near burner.

3.Turn sideburner knob to the position. Be sure burner lights and stays lit.

Burner Flame Check

•Remove cooking grates and troughs. Light burners, rotate

knobs from to . You should see a smaller flame in

position than seen on . Perform burner flame check on sideburner, also. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flame" in the Troubleshooting Section.

Turning Grill Off

•Turn all knobs to OFF position. Turn LP cylinder off by turning hand-wheel clockwise to a full stop.

Ignitor Check

•Turn gas off at LP cylinder. Press and hold electronic ignitor button. "Click" should be heard and spark seen each time between each collector box or burner and electrode. See "Troubleshooting" if no click or spark.

Valve Check

•Important: Make sure gas is off at LP cylinder before checking valves. Knobs lock in OFF position. To check valves, first push in knobs and release, knobs should spring back. If knobs do not spring back, replace valve assembly before using grill. Turn knobs to LOW position then turn back to OFF position. Valves should turn smoothly.

Hose Check

•Before each use, check to see if hoses are cut or worn. Replace damaged hoses before using grill. Use only valve/hose/regulator specified by manufacturer.

General Grill Cleaning

•Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a grill cleaner with scrub brush on insides of grill lid and bottom. Rinse and allow to completely air dry. Do not apply a caustic grill/oven cleaner to painted surfaces.

•Plastic parts: Wash with warm soapy water and wipe dry.

Do not use citrisol, abrasive cleaners, degreasers or a concentrated grill cleaner on plastic parts. Damage to and failure of parts can result.

•Porcelain surfaces: Because of glass-like composition, most residue can be wiped away with baking soda/water solution or specially formulated cleaner. Use nonabrasive scouring powder for stubborn stains.

•Painted surfaces: Wash with mild detergent or nonabrasive cleaner and warm soapy water. Wipe dry with a soft nonabrasive cloth.

•Stainless steel surfaces: To maintain your grill’s high quality appearance, wash with mild detergent and warm soapy water and wipe dry with a soft cloth after each use. Baked-on grease deposits may require the use of an abrasive plastic cleaning pad. Use only in direction of brushed finish to avoid damage. Do not use abrasive pad on areas with graphics.

•Cooking surfaces: If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

463250512 specifications

The Char-Broil 463250512 is a highly regarded propane grill that combines functionality, durability, and modern technology to enhance outdoor cooking experiences. It holds a prominent position among enthusiasts and casual grillers alike, thanks to its thoughtful design and robust features.

One of the standout characteristics of the Char-Broil 463250512 is its impressive cooking capacity. With a primary cooking area of 425 square inches, this grill can accommodate a variety of foods, making it ideal for both intimate family meals and larger gatherings. Additionally, it comes with a porcelain-coated warming rack that offers an extra 150 square inches of space. This versatility ensures that burgers, hot dogs, and vegetables can be cooked simultaneously, providing convenience for multitasking.

The grilling performance of the Char-Broil is powered by four stainless steel burners, each capable of delivering 10,000 BTUs of heat. This total output of 40,000 BTUs allows for fast heating and precise temperature control, ensuring that users can achieve perfectly cooked meats and vegetables. The built-in igniter adds convenience, making it easy to start the grill with the push of a button.

One of the highlighted technologies in the Char-Broil 463250512 is its TRU-Infrared cooking system. This innovative technology helps in distributing heat evenly across the cooking surface, preventing flare-ups and enhancing flavor retention. As a result, meat stays juicy while achieving that coveted, crispy exterior. The infrared system also improves fuel efficiency, allowing users to cook at lower temperatures without sacrificing performance.

Moreover, the grill is constructed with a durable stainless-steel lid and doors, providing both aesthetic appeal and resistance to rust and corrosion. The porcelain-coated grates further enhance durability while making cleanup easier. Additionally, the grill features a side burner for preparing sauces or side dishes, enhancing overall cooking flexibility.

Other practical features include a convenient cart design, side shelves for prep space, and an integrated thermometer to monitor internal grilling temperatures. The grill also comes with wheels for mobility, making it easy to move around your backyard or patio.

In summary, the Char-Broil 463250512 combines style, efficiency, and advanced grilling technology into one versatile package. With its spacious cooking area, powerful burners, and innovative TRU-Infrared technology, it stands out as an excellent choice for both novice and experienced grillers seeking to elevate their outdoor cooking game.