Pride Mobility SC160VBLU, SC170VBLU, SC170CRED, SC160HGRN manual Assembly, Front and Rear Sections

Page 27

I X . D I S A S S E M B LY A N D A S S E M B L Y

ASSEMBLY

1.Pull up on the manual freewheel lever. See VI. “De- scription.” Putting your Victory in freewheel may make it easier for you to maneuver the rear section because the drive wheels are free to turn.

2.Position the front and rear sections of your Victory as shown in figure 17.

3.Align the lower slots on the rear of the front section to the corresponding pegs on the front of the rear section. See figure 18.

4.Gently push the front section of your Victory towards the rear section until the curved locking brackets are fully connected onto the rear pegs.

5.Insert the ball detent pin.

6.Place the cam locks in the locked position. See figure 19.

7.Raise the tiller to the upright position by turning the tiller adjustment lever until it is loose. Raise the tiller to the desired position. Verify that the tiller release but- tons are reengaged, and tighten the tiller adjustment lever.

8.Insert the large, white, 9 pin connector (located on the harness coming out of the Victory’s front section) to the connector’s mating socket (found near the front of the Victory’s rear section). See figure 15.

9.Place the batteries in the battery wells and tighten the battery straps.

10.Connect the 2-pin battery harnesses into the mating harnesses that extend from the electronic controller. See figure 14.

11.Gently place the rear shroud over the seat pedestal and slide it down into position. Seefigure 10. The re- usable fasteners will hold it in place.

12.Carefully lift the seat and slide the seat post (on the bottom of the seat frame) into the seat pedestal. See figure 10.

13.To complete the assembly of your Victory, rotate the seat until it locks into place.

FRONT FRAME HANDLE

FIGURE 17. FRONT AND REAR SECTIONS

CONNECT FRAME HALVES HERE

FIGURE 18. FRAME LOCK

LOCKED POSITION

BATTERY WELLS

FIGURE 19. FRAME CAM LOCKING

LEVERS

Victory

27

Page 26 Page 28
Image 27
Page 26 Page 28
Contents Wheel Scooters F E T Y G U I D E L I N E S N T E N T S ContentsInformation Exchange N T R O D U C T I O NPride Owners Club My Authorized Pride Provider IsQuick Reference Information Ramps and Other Inclines S a F E T YDoors ElevatorsDriving Surfaces Safety PrecautionsS a F E T Y EMI/RFI Warnings EMI/RFI Frequently Asked Questions FaqsWhere do radio waves come from? I . E M I / R FWhat is the FDA doing about the problem? FDA has also requested or recommended thatWhat should I do if my Victory moves unexpectedly? Victory Dimensions Specification SLength Victory 3 46in Victory 4 48in Width E S C R I P T I O N Control Console AssemblyKey Switch Speed Adjustment DialHorn Button Battery Condition MeterLight Switch Throttle Control LeverRear Section Onboard Battery ChargerMain Citcuit Breaker Battery Charger FuseBatteries Electronic Controller ModuleMotor/Transaxle Assembly Manual Freewheel LeverAnti-Tip Wheels Batteries and CHARGING-FREQUENTLY Asked Questions Faqs B a T T E R I E S a N D C H a R G I N GFollow These Easy Steps to Charge Your Batteries Safely What type and size of battery should I use? Use these specifications to reorder deep-cycle batteriesHow can I get maximum range or distance per charge? Why do my new batteries seem weak? To change a battery in your VictoryHow can I ensure maximum battery life? How should I store my Victory and its batteries?What about public transportation? Operating Your Victory PRE-RIDE Adjustments and ChecksI . O P E R a T I O N Getting on Your VictoryGetting OFF of Your Victory Tiller Angle Adjustment Seat Height AdjustmentI I . C O M F O R T a D J U S T M E N T S Seat Lock Lever Armrest Width AdjustmentD I S a S S E M B LY a N D a S S E M B L Y DisassemblyFront and Rear Sections AssemblyP T I O N a L a C C E S S O R I E S B a S I C Troubleshooting What if all the systems on my Victory seem to be dead?What if the motor runs but my Victory does not move? I . C a R E a N D M a I N T E N a N C E Warranty Exclusions THREE-YEAR Limited WarrantyTHREE-YEAR Warranty Exceptions ONE-YEAR Limited WarrantyI I . W a R R a N T Y T E S T E S Susquehanna Avenue Exeter, PA 18643
Top Page Image Contents