Lennox Hearth LBV-4324MN, LBV-3824EN, LBV-4324MP-H manual Damper and Outside AIR Controls, Actuator

					OT
					IL
					P
	O	N
T
		it			TH
O
L
I
P	FFO
					TP
					TPTH
IN			OUT
SIT Millivolt Valve			Gas Control Knob
					Spark Ignitor
Spark Ignitor			Gas Control Knob
					O
					N
				LI	P
			O
			FFO T
Honeywell Millivolt Valve
Figure 2

	6. Remember, Millivolt appliances have a con-
Electronic Gas	tinuous burning pilot flame. Exercise caution
Control Valve
	when using products with combustible vapors.

Fully Open or

Fully Closed

Figure 4

DAMPER AND OUTSIDE AIR CONTROLS

This appliance is fitted with a manually con- trolled vent damper. The vent damper should be closed when the appliance is not in use to prevent cold air from entering the home through the venting system. The damper is controlled through the use of a control lever located within the appliance opening at the top center in front of the firebox lintel (see Figure 5 ). The control lever snaps into place at either extreme of its range of motion. When locked in position all the way to the right, the damper is open. When locked in position all the way to the left, the damper is closed.

PSI
		IGNITE
IN	OFF ON	CONTROL
ON/OFF Switch

Figure 3

2.When lit for the first time, this appliance will emit a slight odor for an hour or two. This is due to the “burn-in” of internal paints and lubricants used in the manufacturing process.

3.Keep lower control compartment clean by vacuuming or brushing at least twice a year. More frequent cleaning may be required due to excessive lint from carpeting, bedding materi- als, etc. It is important that control compart- ments, burners and circulating air passage- ways of the appliance be kept clean.

4.Always turn off gas to the pilot (millivolt appliances) before cleaning. Before re-light- ing, refer to the lighting instructions in this manual. Instructions are also found on a pull- out panel located on the floor of the appliance.

5.Always keep the appliance area clear and free from combustible materials, gasoline and

other flammable liquids.

7.Clean the optional glass doors only when necessary. Wipe surface with clean, damp- ened, soft cloth. Follow with dry, soft towel as desired. Take care not to scratch the glass surface.

WARNING: DO NOT USE ABRASIVE CLEANERS. NEVER CLEAN THE GLASS WHEN IT IS HOT.

CAUTION: DO NOT ATTEMPT TO TOUCH THE DOORS WITH YOUR HANDS WHILE THE FIRE- PLACE IS IN USE. ALWAYS USE DOOR HANDLES. DOORS WILL BECOME VERY HOT WHEN FIREPLACE IS IN USE.

WARNING: FIREPLACES EQUIPPED WITH OPTIONAL ACCESSORY DOORS SHOULD BE OPERATED ONLY WITH THE DOORS FULLY OPEN OR FULLY CLOSED (FIGURE 4 ). THIS APPLI-

ANCE MAY ONLY BE FITTED WITH DOORS CERTIFIED FOR USE WITH THE APPLIANCE.

AVERTISSEMENT: POUR UTILISATION UNIQUEMENT AVEC LES PORTES EN VERRE CERTIFIÊES AVEC L'APPAREIL.

The damper lever actuates a switch, (see wir- ing diagram) which will prevent the appliance main burner from lighting unless the damper is locked open. The appliance flue damper must always remain open when operating.

WARNING: DAMPER MUST BE IN OPEN POSITION WHEN APPLIANCE MAIN BURNER IS OPERATING.

AVERTISSEMENT: LE REGISTRE DOIT ÊTRE EN POSITION OUVERTE LORSQUE LE OU LES BRULEURS PRINCIPAUX DE L'APPEREIL FONCTIONNMENT.

Locked

Closed

Locked

Open

Outside Air

Actuator

Figure 5

4

NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.