Reliance Water Heaters 184123-000 instruction manual Used by this Water Heater

Page 1

Instruction Manual for Residential Manufactured Home Gas Water Heaters

FOR USE ONLY IN MANUFACTURED HOMES

GAMA certification applies to all residential gas water heaters with capacities of 20 to 100 gallons with input rating of 75,000 BTU/Hr. or less.

ALL TECHNICAL AND WARRANTY QUESTIONS: SHOULD BE DIRECTED TO THE LOCAL DEALER FROM WHOM THE WATER HEATER WAS PURCHASED. IF YOU ARE UNSUCCESSFUL, PLEASE WRITE TO THE COMPANY LISTED ON THE RATING PLATE ON THE WATER HEATER.

For Your Safety AN ODORANT IS ADDED TO THE GAS

USED BY THIS WATER HEATER

WARNING: If the information in these instructions are not followed exactly, a fire or explosion may result, causing property damage, personal injury or death.

–Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

–WHAT TO DO IF YOU SMELL GAS

•Do not try to light any appliance.

•Do not touch any electrical switch; do not use any phone in your building.

•Immediately call your gas supplier from a neighbor’s phone. Follow the gas suppli- er’s instructions.

•If you cannot reach your gas supplier, call the fire department.

–Installation and service must be performed by a qualified installer, service agency or the gas supplier.

Save this Manual for Future Reference.

WARNING

Improper installation, adjustment, alteration, service or maintenance can cause DEATH, SERIOUS BODILY INJURY, OR PROPERTY DAMAGE. Refer to this manual for assistance or consult the local gas utility for further information.

WARNING

Flammable vapors may be drawn by air cur- rents from other areas of the structure to this appliance.

WARNING

READ THE GENERAL SAFETY SECTION BEGINNING ON INSIDE COVER AND THEN THIS ENTIRE MANUAL BEFORE INSTALLING OR OPERATING THIS WATER HEATER.

184123-000

03-03

Page 1 Page 2
Image 1
Page 1 Page 2
Contents What to do if YOU Smell GAS Used by this Water HeaterDischarge Pipe General SafetyGeneral Safety cont’d Table of Contents Introduction Preparing for the New InstallationTypical Installation Facts to Consider About the Location Locating the New Water HeaterLocating the New Water Heater cont’d Installing the New Water HeaterFacts to Consider About the Location cont’d Securing Water Heater to Floor and WallWater Piping Installing the New Water Heater cont’dWater Piping Pressure Test Temperature-Pressure Relief Valve Venting Filling the Water HeaterVenting cont’d GAS Piping with Flexible ConnectorGas Piping Sediment TrapFuel Conversion Instructions From Natural Gas To Propane Replace the outer door if not replaced in step Before Lighting the Pilot Installation ChecklistModel Rating Plate Check for Leaks LightingLighting cont’d For Your Safety Read Before LightingTemperature Setting Temperature RegulationStart Up Conditions For Your InformationOperational Conditions For Your Information cont’d High Temperature Shut OFF SystemAIR in HOT Water Faucets Water is TOO HOTBurner Cleaning Periodic MaintenanceVenting System Inspection Burner InspectionPeriodic Maintenance cont’d Leakage Checkpoints This is a Repair Parts LIST, not a Packing List Repair PartsKEY Part Description
Top Page Image Contents