Sears 390.252158 owner manual Contentsintroduction, Read and Follow Safety Instructions

CONTENTSINTRODUCTION

INTRODUCTION/WARRANTY			2
PUMP	PERFORMANCE	.......................................................	3
MAJOR	COMPONENTS	......................................................	3
INSTALLATION			4-5
ELECTRICAL			5_6
OPERATION			7
MAINTENANCE			7-9
HELPFUL HINTS			10
TROUBLESHOOTING		GUIDE	11
REPAIR PARTS			12-14

Please read our instructions before installing and using your shallow Well Water System. This will help you obtain the

full benefits of the quality and convenience built into this

equipment. It will also help you avoid any needless service expense resulting from causes beyond our control which are not _:overed by our warranty.

FULL ONE YEAR WARRANTY ON CRAFTSMAN* WELL PUMP

For one year from the date Of purchase, Sears will repair or replace well pump, free of charge, ff deft:cOve in material or workmanship.

LIMITED WARRANTY ON CRAFTSMAN* PROFESSIONAL HYDRO-GLASS ° WELL PUMP

After one year and through three years from the date of purchase, Sears will fumL_, free of charge, a replacement part for any d_fective part. You pay labor.

FULL FIVE YEAR WARRANTY ON CRAFTSMAN _ CAPTIVE AIR TANK

For rive years from date of purch___e, Sears will repair-or replace the tank, free of chaPge, if defective in material or workmanship.

This x,_arTanty does not cover repairs or replacement parts necessary becaus¢_ of abuse or negligence, inclttding faiinre to install, adjust and operate this pump

according to the instructions in the owners manual

LIMITATION OF LIABILITY

SEARS WILL NOT BE LIABLE FOR LOSS OR DAMAGE TO PROPERTY OR ANY INCIDENTAL OR CONSEQUENTIAL LOSS OR EXPENSE FROM PROPERTY D_LIIAGE DUE DIRECTLY OR INDIRECTLY FROM THE USE OF THIS PRODUCT.

Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to you.

WARRANTY SERVICE LS"A VAILABLE BY SIMPLY CONTACTING THE NEAREST SEARS SERVICE CENTER/DEPARTMENT IN THE UNITED STA TEX

his wan'antyapplies only while this product is in the Unite,J States.

This warranty gives you specific legal rights, and you may also have other rights which ,ra_ from state to state.

Sears, Roebuck and Co., Dept. 817WA, Hoffman Estates, IL 60179

READ AND FOLLOW SAFETY INSTRUCTIONS!

Carefully read and follow all safety instructions in this

manual or on pump.

,_ This is the safety alert symbol. When you see this symbol on your pump or in this manual, look for one

of the following signal words and be alert to the potential for personal injury!

warns about hazards that wiil cause serious

personal injury, death or major property damage if ignored.

[_WARNING ]w ares abou t hazard stha t will or ca n cause se-

rious personal injury, death or major property damage if ig- nored.

&CAUTION ]warns about hazards that will or can cause minor personal injury or property damage if ignored.

The word NOTICE indicates special instructions which are

important but not related to hazards.

] CAUTION ] Never rtm. -pump dry. Running pi_np ¢without

water may cause pump to overheat, damaging seal and pos-

sibly causing burns to persons handling pump. Fill pump with water before starting.

[AWARNING]Never run pump against closed discharge. To do so can boll water inside pump, causing hazardous

pressure in unit, risk of explosion and possibly scalding

persons handling pump.

F[_, CAUTION]7Motor normally operates at high temperature

and will be too hot to touch. It is protected from heat dam-

age during operation by an automatic internal cutoffswitch.

Before handling pump or motor, stop motor and allow to cool for 20 minutes.

1.To avoid risk of serious bodily injury and property dam-

age, read safety instructions carefnily before installing pump.

2.Follow local and/or national plumbing and electrical codes when installing pump,

3.Keep well covered while installing pump to prevent leaves and other debris from falling into well, con- taminating well and possibly damaging pump.

4.Protect pump and piping system from freezing. Allowing pump or water system to freeze could severely damage pump and voids warranty.

LAWARNINGJTo avoid serious injury'and equip-

ment damage, limit system pressure to 100 pounds

per square inch (PSI) or below at all times. Over-

pressure can cause tank blowup; install relief valve

capable of passing full pump volume at 100 PSI.

5.With a new well, test well for purity before use. Consult

local Health Department for procedure.

[AWARNING] Haz._u'dous voltage, Can shock, burn,

cause death, or start fires.