Kenmore 420 Series warranty Leak Test, House Main Water Shutoff Valves, Single Bypass

Page 15

Leak Test

LEAK TEST

To check for leaks, complete the following steps:

CAUTION: To avoid water or air pressure dam- age to softener inner parts, and to flush pipe chips or other residue from the water pipes, be sure to do the following steps exactly as instructed.

1.Fully open two cold, soft water faucets near the softener.

2.Look at the pictures in Fig. 18 and 19 to deter- mine your kind of bypass valve(s). Place bypass valve(s) in “bypass” position. On a single valve, slide the stem inward to bypass. On a three (3) valve system, close the inlet and outlet valves and open the bypass valve.

3.Fully open the house main water pipe shutoff valve. Observe steady water flow from both open faucets.

4.Place bypass valve(s) in SERVICE EXACTLY as follows: Keep soft water faucets open.

a.Single Bypass Valve: Slowly, slide pull the valve stem outward toward service, pausing sev- eral times to allow the softener to pressurize slow- ly.

b.Three Valve Bypass: Fully close the bypass valve and open the outlet valve. Slowly, open the inlet valve, pausing several times to allow the sof- tener to pressurize slowly.

5.After about three minutes, open a hot water faucet for about one minute, or until all air is expelled, then close.

6.Close both cold water faucets.

7.Check your plumbing work for leaks and fix right away if any are found. Be sure to observe previ- ous caution notes.

NOTE: If this procedure is performed on a new softener, water coming from the taps may initial- ly be discolored. This normally occurs the first time water runs through the resin bed. The dis- colored water is not harmful, and the discol- oration will not last more than a few minutes.

Shutoff Valve

FOR SERVICE

Close bypass valve. Open inlet & outlet valves.

FOR BYPASS

Open bypass valve. Close inlet & outlet valves.

HOUSE MAIN WATER

SHUTOFF VALVES

Water

Shutoff Valve

Pressure Tank

Meter

 

 

 

Well Pump

FIG. 17

SINGLE BYPASS

Pull Stem Outward

For Service

Push Inward

For Bypass

Note: Stem may be installed in either direction. The end with writing should be pulled out for service position.

FIG. 18

VALVE BYPASS

Bypass

Valve

Outlet

ValveInlet

Valve

FIG. 19

Questions? Call The Kenmore Water Line 1-800-426-9345

15

Page 14 Page 16
Image 15
Page 14 Page 16
Contents Save this Manual Water SoftenersTEN Year Limited Warranty Against Leaks Warranty on Water SoftenerONE Year Limited Warranty on Water Softener Three Year Limited Warranty on Electronic PartsFacts and Figures to Keep Table of ContentsSafety Guides Inspect Shipment Unpack and Check Your CartonParts Descriptions Small PartsTools Needed Plan Your InstallationProper Order to Install Water Treating Equipment Plan Your InstallationSoft, Hot Where to Install the Water SoftenerDraw in Your Pipes and Fittings Suggested Slab Foundation InstallationPIPE, FITTINGS, Other Materials Needed OUTBefore Installing Checks & Tests Read Before Beginning InstallationInlet and Outlet Threaded Adaptors Install Plastic Bypass ValveAssemble Inlet Outlet ADAPTORS, or Plastic Bypass Valve Bypass ValveValve Bypass Install 3-Valve BypassInstalling Holding Clips Installing 3 Valve Bypass and PipesPosition Softener Into Place Locate Water Softener and Connect PipesMove Softener Into Place Typical Soldering ConnectionsConnect Valve and Salt Tank Drains Connect the Valve Drain HoseConnect Salt Tank Overflow Tubing Leak Test Leak TestHouse Main Water Shutoff Valves Single BypassCold Water Pipe Grounding Water Meter Jumper WireConnecting Transformer Electrical RequirementsProgram the Timer Install Covers and Restart Water HeaterProgram The Timer Install CoversSET Water Hardness Number SET Present Time of DAYRecharge Time SET Regeneration TimeSanitize The Water Softener Sanitize the Water SoftenerSanitize Your Water Softener AS Follows Adding Salt To The Storage Tank Adding Salt to the Storage TankWater Softening Salt with Iron Removing Additives Check List Check List of STEP-BY-STEP Guides to InstallFaceplate Timer Features Options OptionsKCl Units Service Mode KENMORE’S Ultra Cleansing Feature Water Flow Through Softener in Fill Water Flow Through Softener in ServiceSoft Water Service and Regeneration How Your Water Softener WorksWater Flow Through Softener in Backwash Water Flow Through Softener Brining and Brine RinseWater Flow Through Softener Fast Rinse Automatic BypassElectronics Care Of Your Water Softener Salt BridgeSalt Bridge Keeping the Water Softener Clean Iron from Resin BEDNozzle & Venturi Protect the Water Softener from Freezing Drain ALL Water from SoftenerChecklist to Help YOU Save Money Problem Cause CorrectionSpecifications Model 384260 Timer Code H46 Model 394260 Timer Code H47Bypass Valves Performance Claims Always Make These Initial Checks First Service Tech InformationWiring Schematic FaceplateProcedure for Removing Error Code from Faceplate Manual Initiated Electronics DiagnosticsPossible Defect Code Timer PWA Replacement Cycle Flow Rates Gallons PER MIN Manual Advance Regeneration CheckTo Relieve Pressure Rotary Valve ServiceDisassembly AssemblyWater Flow Through the Softener Valve Service Cycle Fill CycleBrining and Brine Rinse Cycle Fast Rinse Cycle Water Flow Through the Softener Valve Backwash CycleFast Rinse Cycle Backwash CyclePage Exploded View Water Softener Complete Parts ListInlet Outlet Grounding Clamps Brine Valve Assembly Wear-Strip Seal Cross-Section View Key Part Number Part Description Get it fixed, at your home or ours

420 Series specifications

The Kenmore 420 Series is a popular line of home appliances designed to elevate the overall cooking experience. This series is a reliable choice for many households, offering a range of advanced features and user-friendly technologies that enhance performance and convenience.

One of the standout features of the Kenmore 420 Series is its powerful heating capabilities. Equipped with a high-performance oven, it ensures that meals are cooked evenly and efficiently. The series often includes multiple cooking modes, such as convection baking and broiling, which provide flexibility for various recipes. This versatility allows users to experiment with their cooking, whether they are baking desserts or roasting meats.

The cooktop design of the Kenmore 420 Series is equally impressive. With multiple burners offering various heat settings, users can simmer, sauté, and boil simultaneously. Many models also incorporate dual burners, which can switch between high and low heat settings, catering to diverse cooking needs. Additionally, the series often features smooth tops, making cleaning a breeze after cooking.

In terms of technologies, the Kenmore 420 Series embraces modern innovations to improve user experience. The presence of smart technology in some models allows homeowners to control their appliances remotely. An integrated app can provide notifications and cooking tips, making meal preparation more convenient than ever.

Energy efficiency is another critical aspect of the Kenmore 420 Series. These appliances are designed to consume less energy while delivering high performance, helping users save on their electricity bills and reduce their environmental footprint. Many models even come with an Energy Star rating, ensuring that they meet stringent energy efficiency guidelines.

Another notable characteristic of the Kenmore 420 Series is its robust construction and design. Built with high-quality materials, these appliances are not only functional but also aesthetically pleasing, blending seamlessly with modern kitchen decor. The ergonomic controls and intuitive interfaces make it easier for users to operate the appliances, regardless of their cooking skills.

Overall, the Kenmore 420 Series stands out as a reliable choice for families and culinary enthusiasts alike. With its powerful performance, innovative technologies, and energy-efficient features, this series meets the varied needs of today's homeowners, making it a staple in many kitchens. Whether you're a novice cook or an experienced chef, the Kenmore 420 Series offers the tools and versatility you need to create delicious meals.
Top Page Image Contents