Bunn RL00006929 service manual Contents Introduction, User Notices

Page 3

CONTENTS

INTRODUCTION

Introduction

2

User Notices

3

Electrical Requirements

4

Plumbing Requirements

4

Initial Set-Up

5

Operating Controls

6

Coffee Brewing

7

Cleaning

7

Troubleshooting

8

Service

12

Wiring Diagrams

26

This equipment will brew a half-gallon batch of coffee into an awaiting decanter at the press of a button. The OL has two and the RL has five warmers to keep the beverage at the right temperature, on the RL one of which is capable of heating water to boiling. The brewer is only for indoor use on a sturdy counter or shelf.

USER NOTICES

Carefully read and follow all notices on the equipment and in this manual. They were written for your protection. All notices on the equipment should be kept in good condition. Replace any unreadable or damaged labels.

!WARNING

Fill water tank before turning - on - thermostat or connecting appliance to power source.

Use only on a properly protected circuit capable of the rated load.

Electrically ground the chassis.

Follow national/local electrical codes. Do not use near combustibles.

FAILURE TO COMPLY RISKS EQUIPMENT DAMAGE, FIRE, OR SHOCK HAZARD

READ THE ENTIRE OPERATING MANUAL BEFORE BUYING OR USING THIS PRODUCT

THIS APPLIANCE IS HEATED WHENEVER

CONNECTED TO A POWER SOURCE

00831.0000F 3/98 ©1998 BUNN-O-MATIC CORPORATION

00831.0000

PN: 00658.0000G 02/08 © 1985 BUNN-O-MATIC CORPORATION

00658.0000

As directed in the International Plumbing Code of the International Code Council and the Food Code Manual of the Food and Drug Administration (FDA), this equipment must be installed with adequate backflow prevention to comply with federal, state and local codes. For models installed outside the U.S.A., you must comply with the applicable Plumb- ing /Sanitation Code for your area.

00656.0001

Page 3

To reduce the risk of electric shock, do not remove or open cover.

No user-serviceable parts inside. Authorized service personnel only. Disconnect power before servicing.

37881.0000

32430 051512

Page 2 Page 4
Image 3
Page 2 Page 4
Contents Phone 217 529-6601 FAX 217 OL & RLBUNN-O-MATIC Commercial Product Warranty User Notices Contents IntroductionElectrical Hook-Up Electrical RequirementsPlumbing Hook-Up Plumbing RequirementsRepeat steps 13-16 until 64 oz water volume is achieved Initial SetupOperating Controls Coffee Brewing CleaningProblem Probable Cause Remedy TroubleshootingMent Troubleshooting Problem Probable Cause RemedyTroubleshooting Problem Probable Cause Probable Cause Remedy Troubleshooting cont. ProblemService Component AccessContents Control Thermostat Service Control ThermostatWarmers Service WarmersService Warmer Switches RL Left Rear, Left Front, Right Rear & Right Front Model Warmer Switch WiringStart Switch Model OL Service Start SwitchSee below Service Indicator LampsLimit Thermostat Service Limit ThermostatSolenoid Valve Service Solenoid ValveRelay Service RelayTank Heater Service Tank HeaterIf voltage is present as described, proceed to #6 Service Water Level and Overflow Safety SwitchMaster ON/OFF Switch Model OL Service Master ON/OFF SwitchSchematic Wiring Diagram SOL WHI Schematic Wiring Diagram OLASchematic Wiring Diagram OL25B Schematic Wiring Diagram OL35B Schematic Wiring Diagram RL L1 L2 N Schematic Wiring Diagram RLA Schematic Wiring Diagram RL35B

RL00006929 specifications

The Bunn RL00006929 is a commercial-grade coffee brewer that exemplifies innovation, efficiency, and durability, making it a preferred choice for coffee shops, restaurants, and large offices. This model is designed to meet high-volume demands while ensuring consistent quality and flavor in every cup.

One of the most notable features of the Bunn RL00006929 is its capacity to brew up to 3.8 gallons of coffee per hour. This remarkable output is facilitated by its dual-funnel design, which allows for simultaneous brewing, reducing wait times and enhancing service speed. The brewer is equipped with a precise temperature control system, ensuring that water is heated to the optimal brewing temperature of 200°F. This consistency in temperature plays a crucial role in extracting the full flavor profile from coffee grounds.

In terms of design, the Bunn RL00006929 boasts a compact footprint, making it suitable for various settings, including kitchens with limited space. The unit features a stainless steel construction, which not only provides a sleek appearance but also contributes to its durability and resistance to corrosion. Additionally, the easy-access design makes maintenance straightforward, allowing operators to clean and service the unit with minimal effort.

The RL00006929 incorporates advanced technologies that enhance its functionality. For instance, the machine features a digital control panel that provides real-time feedback on brewing status, water temperature, and other critical parameters. This intelligent system allows operators to make quick adjustments and ensures that brewing conditions are always optimal.

Another standout characteristic is the integrated brew basket that holds filters securely in place, preventing spills and ensuring a smooth brewing process. This feature minimizes mess and simplifies the coffee-making process, making it user-friendly for both experienced baristas and novice operators.

In summary, the Bunn RL00006929 stands out for its high brewing capacity, precise temperature control, compact design, and user-friendly features. Its combination of advanced technology and durability makes it an excellent investment for any establishment that demands quality coffee at high volumes. With Bunn's reputation for excellence, the RL00006929 is a reliable choice for delivering exceptional coffee experiences.
Top Page Image Contents