Samsung RF26XAEPN If Cover Ice Route MoorGeard Motor is not working normally, Open/Close

Page 83

TROUBLESHOOTING

4-2-15. If Cover Ice Route Moor(Geard Motor) is not working normally

Caution

1.When replacing the Cover Ice Motor, pull out the plug to avoid an electric shock.

2.Be careful! When disassemble the Cover Ice Motor, spring can jumped out and may cause personal injury.

3.Motor will rotate continuously when the Motor Switch is not sensed.

Checking Mehod of Cover Ice Route Motor Resistance

(Make sure to work after Power Off) The Resistance is variable according to

the input voltage.

CN73 and CN74 combined and use same connector(13P)

CN70#9(RED) 13P#9(Blue)

** 0 : Short trouble /

: Open trouble

When the MOTOR rotates.

Start

Does GEARED MOTOR

work properly?

Yes

Is Cubed or Crushed

Ice mode selected on the

LED PANEL?

Yes

Is the DISPENSER

switch selected?

Yes

Does the wiring at the

both sides of motor connected

properly?

Yes

Is the AC input voltage applied to the both ends of the motor?

No

Replace the MOTOR

No

Cubed or Crushed Ice is selected on the LED PANEL PCB

No

Select the DISPENSER switch

No

Check the WIRE

Yes

No

Check the MOTOR/Check any

 

interference on MOTOR rotation

CN73 and CN74 combined and use same connector(13P). Check 13P-”9” Connector / Re-connect

Check the short/open for the SSR75 of Cover Ice Motor on Main PCB. Check the resistance of parallel Connector 13P- 9 , CN70- 9 . (Definitely plug out prior to repair)

Is the sensing

SWITCH connection

normal?

No

Yes

Check/Repair the Housing

connector

 

 

 

 

 

 

Is the switch

No

 

 

 

 

 

pressed area normal when

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

motor rotates?

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Yes

 

Check/Repair the Motor Rotation

 

 

 

 

 

 

 

Operating Condition of Dispenser

 

 

 

 

pressing area

 

 

 

 

Open/Close

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

CN50 - Switch 1,2 Operating

 

 

Are the voltage

Yes

 

 

 

 

 

 

Close

 

ing

Open

 

 

 

 

 

REG1 Heater Sink and CN50-”9”,

 

 

 

Ice Route Switch 1

0V

 

5V

0V

“10” normal?

 

 

 

CN50 - “9” (Purple)

 

 

 

 

 

 

 

 

 

 

 

 

 

Ice Route Switch 2

0V

 

5V

0V

 

No

 

Normal

CN50 - “10” (White)

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Main PCB - Check the wire OPEN/SHORT between the Cover Ice Motor Rotation sensing switches. Check the Short of Cover Ice Motor Control Circuit SSR75 in the MAIN PCB.

Replace the MAIN PCB or the Dispenser Cover Motor.

82

Page 82 Page 84
Image 83
Page 82 Page 84
Contents Refrigerator Important Safety Notice Contents Connector Layout with Part Position Inverter Board Disassembly of Refrigerator Door RightPCB Diagram Connector Layout with Part Position Main BoardPrecautionssafety Warnings Symbols Prohibition Flooring Product Specifications Secure Auto Close Door System Twin Cooling SystemPizza Corner Ice and Water DispenserDryer Fan RefrigeratorRun Time,% DryerInterior Views RF267 Interior Views RF26X Model Specification &Specification Chart OFF C.RFreol Split FIN TypeBsbn Brass Screw FRERefice Room 11/161059mm 19/3215mm 701778mm 6Dimensions of RefrigeratorAmount Optional Material SpecificationDA99-00240S 4713-001223Evaporator Refrigerant Route in Refrigeration cycleHot Pipe Dryer Capillary Tube RefrigeratorCooling Air Circulation Disassembly and Reassembly Assembly & Disassembly On the coupling at first, but must Refrigerator Door Part Name How To Do Descriptive PictureRefrigerator Blue and red clips are notRefrigerator Door Part Name How To Do Descriptive PictureLift the door straight up to remove Door Handle Freezer Door Handle Part Name How To Do Descriptive PictureRemove the Cap Door with a flat-blade- screwdriver Cover-display Refrigerator Light Part Name How To Do Descriptive PictureRefrigerator Light Water-dispenser Part Name How To Do Descriptive Picture Cover-displayWater-dispenser Part Name How To Do Descriptive Picture Remove 4 screws of cover- displayFront plane of the shelf up Glass Shelf Part Name How To Do Descriptive PictureRemove the shelf by lifting Glass ShelfVegetable & Fruit Drawers Shelf Remove 2 screws of the Fold Glass ShelfCool Select Pantry Rail ShelfWater Tank Water Tank Part Name How To Do Descriptive PictureDisengage the housing ConnectorPart Name How To Do Descriptive Picture Water Tank Water Filter Motor Damper Part Name How To Do Descriptive PictureMotor Damper Lifting it up Gallon Door Bin Part Name How To Do Descriptive PictureRemove the gallon door bin by Gallon Door BinVertical Hinged Section Pushing it down Angle mid by pulling it outEvaporator Refrigerator Freezer Door Freezer Door Part Name How To Do Descriptive PictureDoor Handle Lift the drawer up Pull Out Drawer Part Name How To Do Descriptive PictureSlide the drawer in as much as possible Ice Maker Ice-Maker Part Name How To Do Descriptive PictureLever Freezer Light Freezer Light Part Name How To Do Descriptive PictureDoor Switch Freezer Evaporator Freezer Lift up the evaporator coverBlade screwdriver Machine Compartment Part Name How To Do Descriptive PictureMotor Fan Remove the spring with a flatRelay O/L Noise Filter Unscrew 2 screws Disengage the housing connectorUnscrew 2 earth screws PBA Main Electric Box Part Name How To Do Descriptive PictureTroubleshooting Manual defrost of fresh food Test mode manual operation / manual defrost functionFunction for failure diagnosis CompartmentTroubleshooting Self-diagnostic function during normal operation Return to normal display modeTrouble item Trouble contentsSelf-diagnosis Check List LED Self-diagnostics check listDisplay function of Load condition Load mode Check listCooling off mode setting function Code Down KEY control method after converting to option modeRefrigerator control function and is not needed at Service Ex If you want to change the freezer compartment Temperature changing table of fresh food compartmentStandard temperature to 4 2C Resistance Diagnostic method according to the trouble symptomFlow ChartStart Error CodeIf the trouble is detected by self-diagnosis If ICE Maker Sensor has troubleIf R Sensor has trouble Replace the temperature sensorMarking #5R313 due to the SMD Micom If R DEF Sensor has troubleIs the input voltage of IC01 IC01 Micom #72 normal? If Ambient Sensor has trouble#7R307 due to the SMD Micom IC01 Micom #81 normal? If F Sensor has troubleIC01 Micom #77 normal? If F DEF Sensor has trouble#2R310 due to the SMD Micom IC01 Micom #71 normal? If Ice Room Sensor has troubleValue Open trouble Short trouble Typical Ground part are similarChecking method of Pantry Sensor voltage If Pantry Sensor has troubleMicom Pin #73 normal? Normalrecheck Replace Damper Recheck the wire Replace PCB MainIf Pantry Room Damper Heater has trouble If Tank Water Heater has trouble Bad contact of connectorInsert correctly Wire connector Replace Heater Normalrecheck Recheck the wire Replace PCB MainIf FAN does not operateF, R, C FAN Does DC7~12V alternate Ice Room control temperatureIf ICE Room Fan does not operate Yes#37 Test Mode operation will be 30 sec2Test Switch ready If Ice Maker does not operateIf defrost does not operate F,R DEF Heater DEF ErrorIf Power is not supplied Replace Comp Assy If compressor does not operateCheck after 7minutes Replace Micom Replace PCB Replace IC72 Driver ICTD62083APIs manual operation Defrost selected? Is water penetrated into the door switch?If ding-dongsound continuously If beep-beep sounds continuouslyReplacerepair buzzer Replace Panel PCB Replace buzzer Is the damage Or breakage of the buzzer Panel PCB?If Panel PCB does not work normally Reinsert connector, Repair bad contactIs Upper Hinge Panel PCB connector Inserted correctly? Is lighting operate Normally when replace Panel-PCB?Convertible compartment Panel PCB itself has trouble If Pantry Panel PCB is not working normallyDisplay On 0.7V When refrigerator Room Lamp does not light up = For checking the Relay RY78 operating If ICE Water is not suppliedCheck the connection hose If Water is not suppliedTypical PCB Ground CN1#3Black If Cubed or Crushed Ice is not supplied Open/Close If Cover Ice Route MoorGeard Motor is not working normallyExploded VIEW& Parts List Freezer Parts List of Freezer TRAY-DRAWER BOX AW-PJT,PP,COOL White Switch DOOR-FSCREW-TAPPING TH,+,1,M4,L12,ZPCWHT,SWRCH18A REINF-DRAWER BOX AW-PJT,SHP1,T2.0,BLACKRefrigerator Parts List of Refrigerator LEVER-HUMIDITY AW-SEM,TALC PP,COOL White SWITCH-MICROCOVER-VEG REF AW-SEM,HIPS,COOL White KNOB-HUMIDITY QUEEN,ABSASSY-ROLLER B ASSY-ROLLER aAssy CASE-PANTRY AW-SEM CASE-PANTRY AW-SEM,HIPS,COOL WhiteCabinet Parts List of Cabinet GROMMET-LEVER NBR,BLACK AW-SEM,SNOW WhiteAssy Hinge UPP-R HINGE-UPP RGrommet Comp USP05,EPDM,OD18.5,BLACK CBF-POWER CordAssy FAN-CIRCUIT AW-SEM FAN-TURBO AW-SEM,ABS+GLASSFIBERDisassembly of Freeze Door Parts List of Freezer Door AW-PJT,HSWR SLIDER-HANDLE FRESLIDER-HANDLE FRE AW-SEM,POM,I-BLACKSC-00477R SLIDER-HANDLE FRE AW-SEM,POM,NTRDisassembly of Refrigerator DoorLeft Parts List of Refrigerator Door-Left PLATE-FRENCH AW-PJT,SECC1,SNOW White PLATE-FRENCH AW-PJT,SECC1,ALL BlackGASKET-FRENCH AW-PJT,SILICONE,BLACK ASSY-FRENCH AW-SEM,SNOW White101 Disassembly of Refrigerator Door RightParts List of Refrigerator Door-Right PCB Diagram 104 Connector with AC load a. Diode option setting areaPCB Layout with part position PWM Duty PCB Layout with part position Inverter Board1. RF267AE Connector Layout with part position Main Board2. RF26XAE PCB Layout with part position Main BoardConnector Layout with part position Inverter Board Model RF267AE Model RF26XAE Model RF267AE Whole block diagramModel RF26XAE Inverter Board Model RF267AE / RF26XAE Circuit Diagram PN / XAA Refrigerator Division

RF267AEPN, RF267AEXAA, RF267AEWP, RF267AERS, RF26XAEXAA specifications

The Samsung RF267AEBP, RF267AE**, RF26XAERS, RF26XAEPN, and RF26XAE** series of refrigerators are designed to bring convenience and efficiency to modern kitchens. These models embody Samsung's commitment to quality, innovation, and user-friendly technology, making them a popular choice among consumers.

One of the main features of these refrigerators is their stylish design, which combines elegance with functionality. The external finish, often available in sleek stainless steel, enhances the aesthetic of any kitchen while offering durability against scratches and fingerprints.

The interior is thoughtfully organized with adjustable shelves, allowing users to customize the space to fit large and awkwardly sized items. These models commonly include a spacious freezer compartment, equipped with pull-out drawers for easy access to frozen foods. The ice makers and dispensers provide a steady supply of ice and cold water, adding a touch of modern convenience.

Energy efficiency is another key characteristic of the Samsung RF267 series. Many models are ENERGY STAR certified, ensuring they operate well below the federal energy consumption guidelines. This not only helps the environment but also results in lower utility bills for homeowners.

Smart technology is integrated into several versions within this series. Samsung's innovative features like the Food Showcase design enhance organization, enabling users to find items quickly, while the Twin Cooling Plus system maintains optimal humidity and temperature levels in both the refrigerator and freezer compartments. This technology prevents odor mixing and preserves food freshness for a longer time.

The digital display with touch controls allows for easy temperature adjustments and monitoring. Innovative features like the auto pull-out freezer drawer and easy access bins make retrieving food items a breeze.

With advanced filtration systems, these refrigerators ensure clean and fresh-tasting water and ice, providing peace of mind to families. Various safety features, such as door alarms and child locks, enhance usability, especially in households with young children.

In summary, the Samsung RF267AEBP, RF267AE**, RF26XAERS, RF26XAEPN, and RF26XAE** refrigerators represent an ideal combination of style, efficiency, and smart technology. Their commitment to user-friendly features, dependable performance, and environmentally conscious operation makes them stand out in the crowded market of home appliances.
Top Page Image Contents