Maytag 16010107 service manual Relay Board, Value

Page 32

Engineering Mode: Used to view the actual oven temperature for both ovens at all times, even when an oven function is active. This mode will also display the current fault code for 5 seconds in the time digits. Enter the engineering mode by pressing the Bake Key of either oven, enter a bake temperature of 100ºF, then hold Bake down for 3 seconds within 30 seconds of initial Bake press. The mode can be exited by pressing Cancel.

Oven Light: Oven light key toggles the oven light on and off. Oven light is deactivated during a clean cycle.

Dual Line Break Relay: Canadian Models Only. Relay wil be a 17 amp, 240 VAC minimum contact rating. There will also be a

5.6Ohm resistor and a connection to the normally open contact on Canadian models to allow for "Hi-Pot" testing at the factory.

50/60 Hertz Option: Control automatically senses cycle rate of supply line.

Demo Mode: The control can be placed in a sales demo mode by pressing Bake and Cancel keys for 3 seconds. The demo mode can be exited by pressing any key. This mode will activate the display as if the unit is operating without energizing the heating elements.

RELAY BOARD

Relay Board: The relay board will be equipped to operate the following outputs. Some shown can be optional. The Double Line Break (DLB) is located remotely, off board from the main control.

RELAY OUTPUTS

VOLTAGE

CURRENT

RESISTANCE

(Volts AC)

(Amps)

VALUE

 

 

 

 

 

Lower Broil - 3600 Watts

240

15

16 ohms

 

 

 

 

Lower Bake - 2585 Watts

240

10.8

21 ohms

 

 

 

 

Convect*

120

0.28

430 ohms

 

 

 

 

Upper Broil - 2200 Watts

240

9.17

25 ohms

 

 

 

 

Upper Bake - 1800 Watts

240

9.17

25 ohms

 

 

 

 

Upper Oven Light

12

0.8

15 ohms

 

 

 

 

Lower Oven Light

12

0.8

15 ohms

 

 

 

 

Upper Door Lock

120

0.03

4000 ohms

 

 

 

 

Lower Door Lock

120

0.03

4000 ohms

 

 

 

 

Upper Double Line Break

240

17

 

 

 

 

 

Lower Double Line Break

240

17

 

 

 

 

 

SURFACE ELEMENT VALUES

VOLTS

WATTS

RESISTANCE (ohms)

 

 

 

 

Left Front/Right Rear

240

1200

46 ohms

 

 

 

 

Left Rear

240

2200

25 ohms

 

 

 

 

Right Front/Dual

240

750 inner/1450 outer

74 inner/38 outer

 

 

 

 

16010107

Section 5. Troubleshooting

5-3

 

©2000 Maytag Appliances Sales Company

 

Page 31 Page 33
Image 32
Page 31 Page 33
Contents Maytag Gemini Introduction Models Covered in this Manual16010107 Introduction Maytag Appliances Sales Company Contents Wiring Diagrams General Information 16010107 General Information Maytag Appliances Sales Company Electrical Components & Testing Digital Watt/Amp/Volt/Ohm/Temperature MeterElectrical Test Equipment Analog Test MeterPage Component Access Exploded ViewMain TOP ElementsTo Raise Ceran Cooktop Ceran Element CooktopOven Sensor Bake ElementBroil Element Oven Cavity Components Electric Convection Fan ElectricConvect Fan Motor and Blade Electric To Gain Access To Electronic Oven Control Electronic Clock and Oven ControlSignal Lights Oven Light ReplacementHot Surface Light To Replace Oven Light BulbHI-LIMIT Thermostat To Remove Lift-Off DoorUpper Door To Disassemble DoorLower Door Oven Door Hinge Lower Latch AssemblyTo reinstall Oven Racks SpecificationsLeveling Legs Half Rack Accessory Rack PositionsPage To Access Bake Element Upper Oven Only To Access Broil ElementElectrical Oven CircuitsPROBE, Sensor / Both Ovens Surface Elements CeranDuel Element To check oven sensor Surface Indicator LightsHOT Surface Lights Electrical Ratings Surface Element Switch Dual Element SwitchTRANSFORMER, Stepdown Electrical CONNECTIONS/VOLTAGE Range Amperage16010107 Electrical Maytag Appliances Sales Company Troubleshooting Gemini Double Oven ConrolsFault Codes ActivatedRelay Board ValueTroubleshooting Guide Check these points ifTroubleshooting Guide Parts List Replacement Parts Part Name Part NumberFault Identification Summary Fault Suspect Failure Area Correction When CheckedFault Suspect Failure Area Correction When Checked Wiring Diagrams MER6550AA*, MER6550BA* Schematic Diagram MER6550AC, MER6550BC* Wiring Diagram MER6550AC*, MER6550BC* Schematic Diagram 16010107 Wiring Diagrams Maytag Appliances Sales Company 16010107 Wiring Diagrams Maytag Appliances Sales Company MER6770AC*, MER6870AC* Wiring Diagram MER6770AC*, MER6870AC* Schematic Diagram MER6772BA*, MER6872BA* Wiring Diagram MER6772BA*, MER6872BA* Schematic Diagram MER6772BC*, MER6872BC* Wiring Diagram MER6772BC*, MER6872BC* Schematic Diagram Maytag Appliances Sales Company

16010107 specifications

The Maytag 16010107 is a prominent appliance in the world of laundry solutions, offering a blend of durability, efficiency, and advanced technology. As a high-efficiency washer, it stands out for its performance and reliability, appealing to both everyday users and those who prioritize a robust laundry experience.

One of the key features of the Maytag 16010107 is its PowerWash cycle. This innovative washing cycle is designed to tackle tough stains and heavily soiled items with ease. The combination of an optimal wash action, increased wash time, and a powerful cleaning performance ensures that clothes emerge looking fresh and clean.

The Maytag 16010107 is equipped with the Optimal Dose Dispenser, which cleverly holds enough detergent for multiple loads. This feature minimizes waste and ensures that the correct amount of detergent is used every time, promoting efficiency and cost savings for users. Additionally, the washer has a large capacity that can accommodate sizable laundry loads, making it ideal for families or individuals with extensive laundry needs.

Energy efficiency is another hallmark of the Maytag 16010107. The appliance meets stringent Energy Star guidelines, ensuring lower water and energy consumption compared to conventional washers. This not only benefits the environment but also translates into savings on utility bills.

Durability is a core characteristic of Maytag appliances, and the 16010107 is no exception. Built with a robust design and high-quality materials, it is engineered to withstand the rigors of regular use. The washer also features a stainless steel wash basket, which resists chipping and snagging while cleaning clothes, ensuring a longer lifespan for both the appliance and the laundry it cleans.

In terms of user-friendly features, the Maytag 16010107 includes a smooth control panel that is easy to navigate. With multiple wash cycles and settings, users can easily customize their laundry experience based on their specific needs. The washer also boasts a quiet operation, allowing for use without disrupting household activities.

In summary, the Maytag 16010107 combines powerful cleaning performance, energy efficiency, and durable construction. It is designed to meet the demands of modern consumers while delivering the reliability that Maytag is known for. Whether facing everyday laundry challenges or tackling stubborn stains, this washer provides an exceptional laundry experience.
Top Page Image Contents