Craftsman owner manual TRACTOR- MODELNUMBER917.275031 Steeringassembly

Page 41

TRACTOR-" MODELNUMBER917.275031

STEERINGASSEMBLY

KEY	PART
NO.	NO.	DESCRIPTION
1	159944X428 Wheel, Steering
2	178557	Axle Asm., Front
3	6855M	Fitting,Grease
4	161849	SpindleAsm,LH
5	161848	SpindleAsro. RH
6	626_H	Bearing,Race ThrustHarden

7121748X Washer 25/32 x 1-518x 16 Ga.

812000O29 Ring,Klip#T5304-75

9121232X Cap, Spindle

1074781044 Bolt,Fin Hex 5/8-11 x 2-3/4

11136518 Spacer BearingAxle Front

1273901000 Nut, Lock Flange 5/8-11 Uric

13121749X Washer 25/32 x 1-1/4 x 16 Ga.

14ST0551137 Washer, Lock Hvy Hid Spr 5/8

15STD541537 Nut, Lock Center3/8-24 UNF

16	145103	Shaft Asro., Steering
17	137347	Rod Asm. Tie BallJ Ball Vgt (Inc. Key No. 3640)
18	175572	Draglink,BallJoint SolidVgt
19	156011	SupportAsm., SteeringVgt
20	163887X428	Boot,Steering
21	159945	Adapter,Wheel Steering
22	155105	Bushing,Strg. BIk
23	152927	Screw

25STD523710 Bolt,Fin Hex 3/8-16x 1 Gr. 5

26 159946X428 Cap, Wheel Steering

27

3366R

Bearing,Col. Strg.

2817000612 Screw 3/8-16 x 3/4

29104239X Beedng,Flange

31	138136	Bushing,Nyliner Snap
32	19111610	Washer 11/32 x 1 x 10 Ga.
33	74780512	Washer, Lock Hvy Hid Spr 5/16
34	74780512	Bolt, Hex Hd 5/16-18 x 3/4
35	138059	Gear, Sector Steedng
36	137156	Tie Rod

3773360600 Jam NutRH Thread

38109850X JointAsro.BallRH Thread

3973700600 Jam Nut LH Thread

40100851X JointAsm. Ball LH Thread

41

155246

BracketSwitch InterlockVGT 97

4217490508 ScrewThdrol 5/16-18 x 112Tyt

44160135X428 Extension,Steering

4519132411 Washer 13/32 x 1-1120 x 11 Ga.

NOTE: Allcomponentdimensionsgivenin U.S. inches 1 inch = 25.4 mro

41

Image 41

Contents Sears Craftsman Help Line 5 am 5 pm, Mon Sat SEARS, Roebuck and CO., Hoffman ESTATES, ILLimited 90 DAY Warranty on Battery This Warranty does not coverDo not General Operation II. SlopeNever carry children. They may fall off IV. ServiceIII. Children Page Repair Agreement Product SpecificationsCapacity Unleaded Repair Agreement is available on thisSteering 2Flanged PinsSeat Washer 17/32 x %3/16 x 12 Gauge Mower Retainer Spdngs Etainer SpringsHowto SET Upyourtractor Check Battery Tools Required for AssemblyTo Removetractor from Unpack CartonInstall Seat Checktire Pressure Install Mower and Drive BeltRetainer Spring Outward pointing Deck pins Loop Up Check Mower Levelness ChecklistCheck for Proper Position of ALL Belts Check Brake SystemATrACHMENT Lift Lever Parking Brake Shift Lever KnowyourtractorLift Lever Plunger Clutch/Brake Control Howto To Adjust Mower Cutting HeightUseyourtractor To SET Parking BrakeTo Operate Mower To Adjust Gauge WheelsTo Stop Mower Blades To Operate on HillsBefore Startingthe Engine Check Engine OIL Level Towing Carts and Other Attach MentsADD Gasoline To Start EnginePage General Recommendations Lubrication ChartBefore Each USE Tie Rod Ball Joints ZerkBrake Operation BatteryTires Operator Presence SystemTransaxle Cooling BeltsCheck Transaxle OIL Level To Change Engine OILClean AIR INTAKE/COOLING Areas Clean AIR ScreenTo Service PRE-CLEANER CleaningTo Level Mower Housing To Install MowerSIDE-TO-SIDE Adjustment To Remove MowerTo Replace Mower Drive Belt Mower Drive Belt Removal FRONT-TO-BACK AdjustmentBoth Front Links Must be Equal Length To Adjust Brake To Adjust Attachment ClutchTo Replace Mower Blade Drive Belt Sway Bar Bracket Idler PulleyFront Wheel TOE-IN Adjustment To Adjust Steering Wheel ALIGN- MentTo Replace Motion Drive Belt Belt RemovalReplacing Battery To Start Engine with Aweak BatteryTo Remove Wheel for Repairs Front Wheel Rear WheelEngine Preliminary Setting To Adjust Choke ControlTo Adjust Carburetor Engine Fuel System TractorEngineoil CylindersProblem Troubleshooting ChartCause CorrectionReplace blade. Tighten blade bolt Adjust throttle control Clean underside of mowerNot rotatemechanism Battery will NotLow/uneven tire air pressure Place Throttle controlTRACTOR-- Model Number SchematicTRACTOR-- Model NUMBER917.275031 Electrical Eiectrical TRACTOR-- Model NUMBER917,275031Chassis and Enclosures TRACTOR-- Model NUMBER917.275031KEY Part NO. NO.DESCRIPTION TRACTOR-- Model Number Chassis and EnclosuresTRACTOR-- Model Number Ground Drive TRACTOR- Model Number Ground Drive TRACTOR-- Model Number Steering Assembly TRACTOR- MODELNUMBER917.275031 Steeringassembly Spark Arrester KIT J TRACTOR- Model NumberTRACTOR.. Model Number Seat AssemblyDecals Tractor - Model NumberWheels &TIRES LiFT Assembly Mower Deck Tractor - Model Number 917,275031Mower Deck Transaxle KEY Part NO. no XI-7 Description KEY PartBlower Housing and Raffles J Not Illustrated KEY Part NO. NO.DESCRIPTIONKohler ENGINE-MODEL Number CV674, Type Number =-aiINO. NO. Description Crankshaft J Exhaust Fuel System J Crankshaft Fuel System KEY Part Description Page Only Ride UP and Down Hill Not Across Hill Guide Suggested Guide for Sighting Slopes for Safe Operation1888SU-HOGAR Parapedirsewiciodere800YERMC