Craftsman 917.259172 manual Trov Leshoo G POUNT$, Problem Cause Correction

Page 29

TROV LESHOO G POUNT$

PROBLEM

CAUSE

CORRECTION

Engine continues to run when operator leaves sea with attachment clutch

engaged

Poor cut - uneven

Mower blades will not rotate

t.Faulty operator_safety presence control system

t.Worn, bent or loose blade. 2_ Mower deck not level.

3.Buildup of grass, leaves, and trash under mower..

4.Bent blade mandrel.

5.Clogged mower deck vent holes from buildup of grass, leaves, and trash around mandrelsr

t.Obstruction in clutch mechanism

2.Worn/damaged mower drive belt.

3Frozen idler pulley.

4.Frozen blade mandrel.

1.Check wiring, switches and connections It not corrected, contact an authorized service center/ department

tReplace blade. Tighten blade bolt..

2 Level mower deck.

3Clean underside of mower housing.

4Replace blade mandrel..

5Clean around mandrels to open vent holes

1.Remove obstruction

2

Replace

mower drive belt

3

Replace

idler

pulley..

4

Replace

blade

mandrel.

Poor grass discharge

1.

Engine

speed

too

slow

 

 

2.

Travel

speed

too fast

 

 

3.

Wet

grass

 

 

 

 

 

 

 

4.

Mower

deck

not level

 

 

5.

Low/uneven

 

tire air pressure

 

 

6.

Worn,

bent

or loose

blade.

 

 

7.

Buildup of grass, leaves and trash under mower.

 

8.

Mower

drive

belt

 

worn

 

 

9.

Blades

tmproperfy

installed

 

 

10

Improper

blades

used

 

 

11

Clogged

mower

deck vent holes from buildup of

 

 

grass, leaves, and trash around mandrels.

Headlight(s) not working

1.

Switch

is "OFF'.

 

 

 

 

(if so equipped)

2

Bulb(s)

burnedout.

 

 

 

 

3.

Faulty

light

switch.

 

 

 

4.

Loose

or damaged

wiring.

 

 

5

Blown

fuse

 

 

 

 

 

 

Battery will not charge

t..

Bad

battery

cell(s).

 

 

 

 

 

 

2_

Poor

cable

conneclions

 

 

3.

Faulty

regulator

(if so equipped)

 

 

4.

Faulty

alternator.

 

 

 

 

Loss of drive

1

Freewheel

control

in "disengaged"

position..

 

2.

Motion

drive

belt

 

worn, damaged,

or broken.

 

3.

Air trapped

in transmission during

shipment

 

 

or servicing.

 

 

 

 

 

 

Engine "backfires"

1.

Engine

throttle control not set at "SLOW"

when turning engine

 

position

for

30 seconds before stopping engine.

"OFF"

 

 

 

 

 

 

 

 

 

 

 

1.

Place thrott[e control in "FAST" position°

2

Shift to slower speed,

3.Allow grass to dry before mowing

4.Level mower deck..

5.Cheek tires for proper air pressure.

6.Replace/sharpen blade. Tighten blade bolt

7.Clean underside of mower housing..

8, Replace mower drive bell

9_ Reinstall blades sharp edge down

10 Replace with blades listed in thts manual.

11.Clean around mandrels to open vent holes

1.Turn switch "ON"

2Replace bulb(s).

3Check/replace light switch.

4.Check wiring and connections.

5Replace fuse.

1.Replace battery,

2.Check/clean all connections,

3.Replace regulator,

4..Replacealternator0

t Place freewheel control in "engaged" position..

2.Replace motion drive belt

3.Purge transmission

1.Move throttle control to "SLOW" position and allow to idle for 30 seconds before stopping engine.

29

Page 28 Page 30
Image 29
Page 28 Page 30
Contents LiMmmmillllll illi Lllll General Operation Safe Operation Practices for Ride-On MowersNever carry passengers II. Slope OperationCustomer RESPONSIBULmTgES Maintenance AgreementUndex Performance Engine MaintenanceAccesgorieg AN Attachments Contents of HAF DWA E Pack HOW to SET UP Your Tractor Tools Requhred for AssemblyTo Remove Tractor from Carton Unpack CartonCheck for Proper Position of ALL Belts Install Seat See FigCheck Brake System Assemble Gauge Wheels to Mower Deck See FigInstall iVlULCHER Plate See Figs ChecklistAssem LY To Convert to Bagging or DischargingLock OperationKnow Your Tractor OPERATmONTo Adjust Mower Cutting Height HOW to USE Your TractorTo Operate on Hills Before Starting the EnguneTo Transport See Fig Check Engine OiL Level See FigHydrostatic Transmission Warm UP Purge TransmissionImportant should Your Transmission Require Before Operating the TractorMAX1f3 Mulchrng Iviowing TipsRegularservice Ervioe Dates Lubrication ChartGeneral Recommendations Before Each USETractor Oustome Respon IlitiesTransaxle Pump Fluid Transaxle CoolingLubrication AIR Filter See FigMuffler CLEAN6NGSpark Plugs IN-LINE Fuel Filter See FigTo Remove Mower See Fig To Install Mower See FigSided $£RV C£ AN AdjustmentsTo Level Mower Housing To Replace Motion Drive Belt To Replace Mower Blade Drive Belt See FigClutching ENGINE----.,.. !1Servbce AN Adjustments To Start Engine with a Weak Battery Service and AdjustmentsSee Fig To Replace Headlight BulbEngine To Adjust Throttle Control CableTo Adjust Choke Control See Fig DEPARTMENT, Which has Proper Equipment To Adjust Carburetor See FigsERV CE Other EngbneFuel System Engine OILTrou Leshooting POre TS Problemcause CorrectionTrov Leshoo G POUNT$ Problem Cause CorrectionPage Tractor -- Model Number SchematicElectrical Tractor - Model Number 917=259172Description Tractor --MODEL NumberKEY Part NO. no Chassis and Enclosures REPAnR PartsStlt KEY Part NO. NO.DESCRIPTION150 151 Tractor - Model Number 917,259172Drive NOo no KEY PartKEY Part Description UNCTractor - Model Number Steering AssemblySTLT/GT Tractor - Model NumberEngine Optional EquipmentRepair Parts Clip Push-In Seat AssemblyStlth DecalsWheels Tires 13 --y Mower Lift161718 Rod Adj. Lift 28 STD541237 Nut Hex Jam 3/8-16 Mower LiftSTD560907 Pin cotter 3/32 Mower Deck TRACTOR-- Model Number Hydro Gear Transaxle Model Number Tractor -- Model NumberLower 220 615 q 552534 642 165 643 535 523 445 422Pump Repair KIT Gasket SET803 653 311544 201Requires Special Tools 8A9 572305 304 308A 307 306 Description KEY Part KEY PartPin, Float Hinge 394961KEY Part Description NO. no Service Notes $ERVRCE Notes Service Notes LLI LU U For Repair SERVICE, Call this Toll Free Number If YOU Need Repair Service Or Parts164030 12.4.97 RD Model Number Engine Model NO. 42E707-2631-E1

917.259172 specifications

The Craftsman 917.259172 is a versatile lawn tractor designed to meet the needs of homeowners seeking an efficient and reliable machine for maintaining their lawns and garden landscapes. This riding mower is equipped with a powerful engine and a set of features that enhance its performance, making it ideal for residential use.

At the heart of the Craftsman 917.259172 is a robust 17.5 horsepower Briggs & Stratton engine. This reliable engine provides the power needed to tackle various mowing tasks with ease. The automatic transmission allows for smooth and effortless operation, enabling users to easily adjust their speed according to the terrain. Whether navigating through uneven grounds or tackling larger lawns, this tractor adapts seamlessly, ensuring a consistent mowing experience.

One of the standout features of the Craftsman 917.259172 is its 42-inch cutting deck. This wide deck allows for efficient mowing, reducing the number of passes needed to cover larger areas. The deck also features adjustable cutting heights, giving users the flexibility to choose their preferred grass length. With five different cutting positions, it caters to the varying needs of different types of grass and weather conditions.

The tractor is designed with user comfort in mind. It incorporates a soft-grip steering wheel, making it easier for users to maneuver around their gardens. The padded seat offers comfort for extended mowing sessions, ensuring that operators can work without fatigue. Additionally, the compact size of the tractor enhances its maneuverability, allowing users to reach tight spots with ease.

In terms of technology, the Craftsman 917.259172 showcases a simple yet effective control panel, making it user-friendly. The easy-to-read gauges help keep track of fuel levels and cutting height, providing essential information at a glance. For added convenience, this lawn tractor features a rear bagger attachment option, allowing for efficient clippings collection and disposal.

Durability is a key characteristic of the Craftsman 917.259172. Its steel frame construction and quality materials ensure longevity and resilience against wear and tear caused by regular mowing tasks. Users can trust that this lawn tractor will remain robust and reliable over the years, providing great value for their investment.

In summary, the Craftsman 917.259172 offers a combination of power, versatility, and user-friendly features that make it a top choice for homeowners looking to maintain their lawns efficiently. With its strong engine, wide cutting deck, and comfort-driven design, this lawn tractor stands out as an excellent option for those seeking a reliable mowing solution.
Top Page Image Contents