Weed Eater WET2242STB manual Tools Required For Assembly, To Remove Tractor From Carton

Page 6
ASSEMBLY

ASSEMBLY

Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness.

TOOLS REQUIRED FOR ASSEMBLY

A socket wrench set will make assembly easier. Standard wrench sizes are listed.

(2)

7/16" wrenches

Utility knife

(2)

3/4" wrench

Tire pressure gauge

Pliers

When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel).

TO REMOVE TRACTOR FROM CARTON

UNPACK CARTON

•Remove all accessible loose parts and parts cartons from carton.

•Cut along dotted lines on all four panels of carton. Remove end panels and lay side panels flat.

•Check for any additional loose parts or cartons and remove.

BEFORE REMOVING TRACTOR FROM SKID

ATTACH STEERING WHEEL (See Fig. 1)

ASSEMBLE EXTENSION SHAFT AND BOOT

•Slide extension shaft onto lower steering shaft. Align mounting holes in extension and lower shafts and install 1/4 hex bolt and locknut. Tighten securely.

IMPORTANT: TIGHTEN BOLT AND NUT SECURELY TO 10-12 FT. LBS TORQUE.

•Place tabs of steering boot over tab slots in dash and push down to secure.

INSTALL STEERING WHEEL

•Position front wheels of the tractor so they are pointing straight forward.

•Remove steering wheel adapter from steering wheel and slide adapter onto steering shaft extension.

•Position steering wheel so cross bars are horizontal (left to right) and slide inside boot and onto adapter.

•Assemble large flat washer, 1/2 hex nut and tighten securely.

•Snap steering wheel insert into center of steering wheel.

•Remove protective materials from tractor hood and grill.

IMPORTANT: CHECK FOR AND REMOVE ANY STAPLES IN SKIDTHAT MAY PUNCTURETIRESWHERETRACTOR IS TO ROLL OFF SKID.

 

INSERT

 

1/2 HEX NUT

 

LARGE FLAT

 

WASHER

STEERING

 

WHEEL

STEERING

 

 

BOOT

 

TABS

ADAPTER

 

 

EXTENSION SHAFT

 

1/4 HEX BOLT

1/4 LOCKNUT

 

LOWER

 

STEERING

 

SHAFT

 

 

TAB

 

SLOTS

FIG. 1

6

Page 5 Page 7
Image 6
Page 5 Page 7
Contents MODEL NO. WET2242STB 22.0HP 42 Inch Lawn Tractor SAFE OPERATION PRACTICES FOR RIDE-ONMOWERS SAFETY RULESIV. SERVICE I. GENERAL OPERATIONSAFETY RULES TABLE OF CONTENTS PRODUCT SPECIFICATIONSCUSTOMER RESPONSIBILITIES Seat CONTENTS OF HARDWARE PACKSteering Wheel KeysTO REMOVE TRACTOR FROM CARTON ASSEMBLYTOOLS REQUIRED FOR ASSEMBLY BEFORE REMOVING TRACTOR FROM SKIDHOW TO SET UP YOUR TRACTOR INSTALL SEAT See FigCHECK BATTERY See Fig CHECK FOR PROPER POSITION OF ALL BELTS CHECK TIRE PRESSURECHECK DECK LEVELNESS CHECK BRAKE SYSTEMOPERATION KNOW YOUR TRACTOR TO SET PARKING BRAKE See Fig HOW TO USE YOUR TRACTORTO ADJUST MOWER CUTTING HEIGHT See Fig TO USE THROTTLE CONTROL See FigTO OPERATE ON HILLS BEFORE STARTING THE ENGINETO OPERATE MOWER See Fig TO TRANSPORTMOWING TIPS TO START ENGINE See FigGENERAL RECOMMENDATIONS MAINTENANCELUBRICATION CHART BEFORE EACH USEBRAKE OPERATION BATTERYTRACTOR TIRESENGINE CLEAN AIR SCREENCLEAN AIR INTAKE/COOLING AREAS V-BELTSSPARK PLUGS CLEANINGMUFFLER IN-LINEFUEL FILTER See FigSERVICE AND ADJUSTMENTS TO INSTALL MOWER See FigTO REMOVE MOWER See Fig TO LEVEL MOWER HOUSING TO REPLACE MOWER BLADE DRIVE BELT See Fig.TO CHECK AND ADJUST BRAKE See Fig. TO REPLACE MOTION DRIVE BELT See FigTO ADJUST STEERING WHEEL ALIGN- MENT FRONT WHEEL TOE-IN/CAMBERTO REMOVE WHEEL FOR REPAIRS See Fig TO REMOVE HOOD AND GRILL ASSEMBLY See Fig TO START ENGINE WITH A WEAK BATTERY See FigREPLACING BATTERY See Figs. 24 and TO REPLACE HEADLIGHT BULBTO ADJUST THROTTLE CONTROL CABLE TO ADJUST CHOKE CONTROLTO ADJUST CARBURETOR FUEL SYSTEM STORAGEOTHER ENGINE OILCAUSE TROUBLESHOOTING POINTSPROBLEM CORRECTIONEngine continues to run REPAIR PARTS SCHEMATICELECTRICAL 42 2441 43 27 27 25 33 30PART DESCRIPTIONCHASSIS AND ENCLOSURES chassis-pl.lt stlt180679 17670508DRIVE REPAIR PARTS 71 29 46 8 6 17 2 7 STEERING ASSEMBLY38 12 11 26 28 10REPAIR PARTS ENGINE OPTIONAL EQUIPMENTSpark Arrester 139277 180645124028X 3645JSEAT ASSEMBLY DECALS WHEELS & TIRESMOWER LIFT 11 19 13 31 32 13 31 7 8MOWER LIFT MOWER DECK 42_deck_man-t-path_3REPAIR PARTS SERVICE NOTES LIMITED WARRANTY E. No Dealer Warranty NEW PEERLESS GEAR POWER TRAIN COMPONENTSC. Securing Warranty Service LIMITED WARRANTIES FORTHIS FOLDALONG DOTTED
Top Page Image Contents