Weed Eater 191087 manual Table of Contents

Page 4

PRODUCT SPECIFICATIONS

GASOLINE CAPACITY

2.0 GALLONS

AND TYPE:

UNLEADED REGULAR

 

 

OIL TYPE (API-SF-SJ):

SAE 30 (above 32°F)

 

SAE 5W-30 (below 32°F)

 

 

OIL CAPACITY:

W/FILTER 3.9PINTS

 

W/O FILTER 3.4 PINTS

SPARK PLUG:

CHAMPION RN4C

(GAP: .030")

 

 

 

 

GROUND SPEED (MPH):

FORWARD:

 

1st

1.1

 

2nd

1.4

 

3rd

2.2

 

4th

3.3

 

5th

4.4

 

6th

4.9

 

REVERSE:

1.4

TIRE PRESSURE:

FRONT:

14 PSI

 

REAR:

12 PSI

 

 

CHARGING SYSTEM:

16 AMPS @ 3600RPM

 

 

 

BATTERY:

AMP/HR:

35

 

MIN. CCA:

280

 

CASE SIZE:

U1R

 

 

BLADE BOLT TORQUE:

27-35 FT. LBS.

CONGRATULATIONS on your purchase of a new tractor. It has been designed, engineered and manufactured to give you the best possible dependability and performance.

Should you experience any problem you cannot easily rem- edy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor.

Please read and retain this manual. The instructions will enable you to assemble and maintain your tractor properly. Always observe the “SAFETY RULES”.

CUSTOMER RESPONSIBILITIES

•Read and observe the safety rules.

•Follow a regular schedule in maintaining, caring for and using your tractor.

•Follow the instructions under “Maintenance” and “Stor- age” sections of this owner’s manual.

WARNING: This tractor is equipped with an internal com- bustion engine and should not be used on or near any unimproved forest-covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.

A spark arrester for the muffler is available through your nearest authorized service center/department (See REPAIR PARTS section of this manual).

TABLE OF CONTENTS

SAFETY RULES

2-3

PRODUCT SPECIFICATIONS

4

CUSTOMER RESPONSIBILITIES

4

ASSEMBLY

6-8

OPERATION

9-13

MAINTENANCE SCHEDULE

14

MAINTENANCE

14-17

SERVICE AND ADJUSTMENTS

18-23

STORAGE

24

TROUBLESHOOTING

25-26

REPAIR PARTS

28-43

WARRANTY

45

4

Page 3 Page 5
Image 4
Page 3 Page 5
Contents Model NO. WET2242STD Safety Rules Safety Rules Table of Contents Contents of Hardware Pack Assembly Tools Required for AssemblyTo Remove Tractor from Carton Before Removing Tractor from SkidInstall Seat See Fig Check Battery See FigCheck Tire Pressure Check Deck LevelnessCheck for Proper Position of ALL Belts Check Brake SystemOperation Know Your Tractor HOW to USE Your Tractor Before Starting the Engine Mowing Tips To Start Engine See FigMaintenance Lubrication ChartGeneral Recommendations Before Each USETractor Engine Cleaning MufflerSpark Plugs IN-LINE Fuel Filter See FigTo Install Mower See Fig Service and AdjustmentsTo Remove Mower See Fig To Level Mower Housing Belt InstallationTo Replace Mower Blade Drive Belt See Fig Belt RemovalTo Check and Adjust Brake See Fig To Adjust BrakeTo Replace Motion Drive Belt See Fig To Check BrakeTransaxle Gear Shift Lever NEUTRAL- Adjustment See Fig To Adjust Steering Wheel ALIGN- MentFront Wheel TOE-IN/CAMBER To Remove Wheel for Repairs See FigInterlocks and Relays To Replace Headlight BulbTo Replace Fuse To Adjust Choke Control To Adjust Throttle Control CableTo Adjust Carburetor Storage OtherFuel System Engine OILTroubleshooting Points With attachment clutch Schematic Tractor - Model Number WET2242STDElectrical 144927 183759Chassis and Enclosures 179174X010 17 183394X550 Hood 126938X183552 174714Drive 173937 7449054472110622 17490510Steering Assembly 72110618 40 73540600 Nut 186737188967 Engine 184900 Seat Assembly 188704180166 180186Decals Mower Lift Repair Parts Mower Deck 73900600 19091210188234 187690Service Notes Limited Warranty Policy Suggested Guide for Sighting Slopes for Safe Operation Only Ride UP and Down Hill Not Across Hill Degrees MAX
Top Page Image Contents