White Outdoor HW-656 manual Trouble Shooting Guide, OFF-SEASON Storage

Page 15

•Loosen the center hex bolt and lower the blade and engine pulley until there is adequate clearance to move the belt past the belt keeper.

•Remove the belt from the engine pulley and around the blade. See Figure 19.

•Reassemble in reverse order with new belt (part # 754-0465).

NOTE: Begin idler reassembly by inserting bolt up through the idler bracket hole. Adjust the drive clutch following instructions on page .

Engine

Remove belt

Pulley

 

 

from around

 

 

 

 

 

pulley and

 

 

blade

Hex Bolt

Figure 19

SECTION 8: OFF-SEASON STORAGE

The following steps should be taken to prepare lawn mower for storage.

•Clean and lubricate mower thoroughly as described in the lubrication instructions.

•Refer to engine manual for correct engine storage instructions.

•Coat mower’s cutting blade with chassis grease to prevent rusting.

•Store mower in a dry, clean area. Do not store next to corrosive materials, such as fertilizer.

NOTE: When storing any type of power equipment in an unventilated or metal storage shed, care should be taken to rust-proof the equipment. Using a light oil or silicone, coat the equipment, especially cables and all moving parts.

SECTION 9: TROUBLE SHOOTING GUIDE

Trouble

Possible Cause(s)

Corrective Actions

Engine fails to

1.

Blade control handle disengaged.

1.

Engage blade control handle.

start

2.

Spark plug wire disconnected.

2.

Connect wire to spark plug.

 

3.

Dirty air cleaner.

3.

Refer to the engine manual.

 

4.

Primer button not depressed.

4.

Refer to the engine manual.

 

5.

Throttle control lever not in correct position.

5.

Move throttle lever to FAST or START position.

 

6.

Fuel tank empty or stale fuel.

6.

Clean fuel line.

 

7.

Blocked fuel line .

7.

Clean, adjust gap or replace.

 

8.

Faulty spark plug.

8.

Refer to the engine manual.

 

9.

Engine flooded.

9.

Wait for a while and crank the engine.

Engine runs

1.

Unit running in START position.

1.

Move throttle lever to FAST position.

erratic

2.

Spark plug wire loose.

2.

Connect and tighten spark plug wire. Check for fouling.

 

3.

Blocked fuel line or stale fuel.

3.

Clean fuel line; fill tank with clean, fresh gasoline.

 

4.

Carburetor out of adjustment.

4.

Refer to the engine manual.

Engine

1.

Engine oil level low.

1.

Fill crankcase with proper oil.

overheats

2.

Dirty aircleaner.

2.

Refer to the engine manual.

 

3.

Air flow restricted.

3.

Stop engine and disconnect spark plug wire. Remove

 

 

 

 

blower housing and clean.

 

4.

Carburetor not adjusted properly.

4.

Refer to the engine manual.

Occasional skip

1.

Spark plug gap too close.

1.

Adjust gap to .030".

at high speed

2.

Carburetor adjustment improperly set.

2.

Refer to the engine manual.

Idles poorly

1.

Spark plug fouled, faulty or gap too wide.

1.

Reset gap to .030" or replace spark plug.

 

2.

Carburetor not adjusted.

2.

Refer to the engine manual.

Excessive

1.

Cutting blade loose or unbalanced.

1.

Tighten blade and adapter. Balance blade.

vibration

2.

Bent cutting blade.

2.

See an authorized service dealer.

Mower will not

1.

Engine speed too low

1.

Set throttle between 3/4 and full throttle.

mulch grass

2.

Wet grass.

2.

Wait until later to cut.

 

3.

Excessively high grass.

3.

Mow once at a high cutting height, then mow again at

 

 

 

 

desired height.

Uneven cut

1.

Wheels positioned incorrectly.

1.

Place all four wheels in same height position.

 

2.

Dull blade.

2.

Sharpen or replace blade.

NOTE: For repairs beyond the minor adjustments above, contact your local White Outdoor dealer.

15

Page 14 Page 16
Image 15
Page 14 Page 16
Contents Operator’s Manual Table of Contents General Operation Important Safe Operation PracticesDo not ServiceSlope Operation ChildrenYour Responsibility O L S Slope GaugeAssembling Your Lawn Mower Attaching Grass Catcher To Mower Converting To Side Discharge Know Your Lawn MowerOperating Your Lawn Mower Handle Height Adjusting Throttle SpeedUsing Your Rotary Mower Using the MulcherReplacing Rear Flap Adjusting Drive Clutch ControlMaintaining Your Lawn Mower Cutting HeightEngine LubricationBlade Care Replacing Drive Belt To Sharpen BladeBlade Mounting Torque OFF-SEASON Storage Trouble Shooting GuideParts List for Model HW-656 Model HW-656 39 33 Ref. No Description MANUFACTURER’S Limited Warranty for

HW-656 specifications

The White Outdoor HW-656 is a versatile and powerful utility tractor designed for both commercial and residential use. With its robust construction and advanced features, the HW-656 stands out in the crowded market of outdoor equipment.

One of the main features of the HW-656 is its powerful engine. Equipped with a reliable Briggs & Stratton engine, the tractor delivers consistent performance and high torque. This makes it ideal for heavy-duty tasks such as mowing large lawns, towing trailers, and even performing snow removal in colder months.

The HW-656 also showcases a unique transmission system. Its hydrostatic transmission provides a seamless driving experience, allowing operators to adjust speed without needing to shift gears. This feature enhances maneuverability, making it easier to navigate tight spots and uneven terrain.

Comfort is another focus in the design of the HW-656. The tractor comes with an ergonomic seating arrangement and adjustable controls, which reduce operator fatigue during extended use. The spacious footwell and cushioned seat ensure that users can work comfortably for hours, whether they are mowing fields or hauling materials.

In terms of attachment compatibility, the HW-656 excels due to its integrated hitch system. This allows for easy attachment of various implements such as plows, cultivators, and lawn sweepers, making it a multi-functional tool suitable for various gardening and landscaping tasks.

Safety features are also a notable aspect of the HW-656. The tractor includes a roll-over protection system, ensuring that users remain safe even in challenging conditions. Additionally, the intuitive control layout makes it easy for users to operate essential functions without distraction.

Another significant characteristic of the HW-656 is its durability. Built with high-quality materials, this tractor can withstand the rigors of tough outdoor work. Its weather-resistant coating helps protect against rust and damage, ensuring longevity even in harsh environments.

Overall, the White Outdoor HW-656 is a reliable and efficient choice for anyone looking to tackle outdoor chores, from lawn maintenance to heavy-duty hauling. Its powerful engine, comfortable design, versatile attachments, and robust safety features make it a standout option in the outdoor power equipment market.
Top Page Image Contents