White Outdoor 83M warranty Maintaining Your Lawn Mower

Page 10

5

Maintaining

Your Lawn

Mower

WARNING

Always stop engine, disconnect spark plug, and ground against engine before cleaning, lubricating or doing any kind of maintenance on your machine.

IMPORTANT: We do not recommend the use of pressure washers or a garden hose to clean your unit. These may cause damage to electric components, spindles, pulleys, bearings, or the engine. The use of water will result in shortened life and reduce serviceability.

Figure 5-1: Lubrication areas on the mower.

A

B

Figure 5-2: Replacing the rear flap.

General Recommendations

•Always observe safety rules when performing any maintenance.

•The warranty on this lawn mower does not cover items that have been subjected to operator abuse or negligence. To receive full value from warranty, operator must maintain the lawn mower as instructed here.

•Changing of engine-governed speed will void engine warranty.

•All adjustments should be checked at least once each season.

•Periodically check all fasteners and make sure these are tight.

WARNING: Always stop engine, disconnect spark plug, and ground against engine before servicing the unit.

Lubrication

1.Lubricate pivot points on the blade control at least once a season with light oil. The blade control must operate freely in both directions, Figure 5-1.

2.Lubricate the wheels at least once a season with light oil (or motor oil). If wheels are removed for any reason, lubricate surface of the axle and inner surface of the wheel with light oil, Figure 5-1.

3.Lubricate the torsion spring and pivot point on the rear discharge door periodically with light oil to prevent rust, Figure 5-1.

4.The transmission is pre-lubricated and sealed at the factory and does not require lubrication.

5.Follow the accompanying engine manual for lubrica- tion schedule and instruction for engine lubrication.

Deck Care

1.Disconnect spark plug wire. Drain gasoline from lawn mower or place a piece of plastic under the gas cap.

2.Tip mower so that it rests on the housing. Keep the side with the air cleaner facing up. Hold mower firmly.

WARNING: Never tip the mower more than 90 degrees in any directions and do not leave the mower tipped for any length of time. Oil can drain into the

upper part of the engine causing a starting problem.

3.Scrape and clean the underside of the deck with a suitable tool. Do not spray with water.

4.Put the mower back on its wheels on the ground. If you had put plastic under the gas cap earlier, make sure to remove it now.

Engine Care

NOTE: Refer to the engine operation and mainte- nance sections in this manual for instructions.

1.Maintain oil level.

2.Service air cleaner every 25 hours under normal conditions. Clean every few hours under extremely dusty conditions.

3.Clean spark plug and reset the gap once a season.

4.Clean engine regularly with a cloth or brush. Keep the cooling system (blower housing area) clean to permit proper air circulation. Remove all grass, dirt, and combustible debris from muffler area.

Replacing Rear Flap

1.Lift up rear door.

2.Bend (bow) the rear flap inward on each side to release tabs from the holes in the handle mounting brackets, Figure 5-2.

3.Replace with new flap by bending the rear flap and sliding into place.

10

Page 9 Page 11
Image 10
Page 9 Page 11
Contents MTD LLC, P.O. BOX 361131 CLEVELAND, Ohio Inch Self-Propelled Rotary Mower Model 83M01/26/2006 Finding and Recording Model Number Table of ContentsCustomer Support Slope Gauge This power machine to persons who read, understand Safe Operation PracticesSlope Operation Seated properly in the handle Remove hand knobs from handle mountingBrackets Rope guide, FigureCutting Height Setup AdjustmentAdjustments Drive ControlKnow Your Lawn Mower Operating Your Lawn Mower Maintaining Your Lawn Mower Blade Care Belt CareOff-Season Storage Page Trouble Shooting Problem Cause RemedySafety Labels Safety Labels Found On Your Lawn MowerCm below lowest portion of neck to allow for fuel expansion Do not choke carburetor to stop engineInternational Symbols and Meanings Safety Label LocationGrass, brush, etc., can catch fire Know Your Engine Operating Your EnginePre-Operation Check Starting The Engine Check Oil LevelCheck Fuel Level Stopping The EngineOil Change Oil ServiceMaintaining Your Running engine until fuel tank is emptyAir Cleaner Kit Part Number Air Cleaner ServiceSpark Plug Service Maintaining Your EngineRemoving From Storage Clean EngineStorage Spark Plug Part NumberPage Shown for reference Reference Parts List 1210 735-04059 Rubber Grommet Drive Control AssemblyDrive Control Cable Upper Engine PulleyEngine 1P70 Illustrated Parts List Fuel TankMANUFACTURER’S Warranty Coverage Carburetor and internal parts Dealer MTD LLC, P.O. BOX 361131 CLEVELAND, Ohio 44136-0019 Phone

83M specifications

The White Outdoor 83M is a noteworthy entry in the world of outdoor power equipment, particularly known for its reliability and versatility. This walk-behind mower is designed primarily for homeowners looking for a robust machine that can handle a variety of lawn care tasks with ease.

A standout feature of the White Outdoor 83M is its powerful engine. Equipped with a reliable Briggs & Stratton engine, it offers dependable performance and starts effortlessly, making mowing a hassle-free experience. The engine generates ample power to tackle thick grass and uneven terrain, ensuring that users can maintain their lawns efficiently.

The cutting deck of the White Outdoor 83M is another highpoint. It typically features a 21-inch steel deck that provides a wide cutting path, allowing users to cover more ground in less time. The adjustable cutting height settings are easily accessible, enabling operators to customize the cut from low to high, accommodating different grass types and personal preferences.

One of the more advanced technologies found in the White Outdoor 83M is its mulching capability. This feature allows the mower to finely chop clippings and distribute them back onto the lawn, providing natural fertilization and reducing yard waste. Additionally, it often comes equipped with side discharge and rear bagging options, so users can choose the best method for their lawn maintenance needs.

The ergonomics of the White Outdoor 83M are designed for user comfort and convenience. Its adjustable handlebars ensure a comfortable grip for operators of varying heights, while its lightweight design and easy maneuverability make navigating around obstacles a breeze. The rear-wheel drive system enhances traction and control, even on sloped or uneven lawns.

Another characteristic worth noting is the mower's durable construction. Built with high-quality materials, the White Outdoor 83M is designed to withstand the rigors of outdoor use over time.

In summary, the White Outdoor 83M combines a powerful engine, versatile cutting options, and user-friendly features that make it a solid choice for homeowners seeking a dependable lawn mower. Its blend of technology and design not only enhances productivity but also simplifies the mowing process, making lawn care a more enjoyable endeavor.
Top Page Image Contents