Multiquip manual GA-6HE/GA-6HEA Controls and Indicators

Page 19

GA-6HE/GA-6HEA — CONTROLS AND INDICATORS

Figure 3E. Generator Components

14. Fuel Cock Lever – Turn this lever downward to start (down)the flow of fuel into the carburetor.Turn upward to stop (up) the flow of fuel.

15. Spark Plug – Provides spark to the ignition system. Set spark plug gap to 0.6 - 0.7 mm (0.028 - 0.031 inch) Clean spark plug once a week.

16. Muffler/Heat Shield – Used to reduce noise and emissions. NEVER touch this heat shield when the generator/welder is in use. Always allow time for the generators to cool down before performing maintenance.

17. Choke Lever – Used for starting the engine. Close the choke lever when starting a cold engine or in cold weather conditions.The choke enriches the fuel mixture. Open the choke lever if starting a warm engine or in warm weather conditions.

18. Recoil Starter (pull rope) – Manual-starting method. Pull the starter grip until resistance is felt, then pull briskly and smoothly.

19.Engine Oil Filler Cap – Remove this cap/dipstick when the adding of engine oil is required. See Table 5 for recommended type engine oil.

20.Engine Oil Drain Plug – Remove this drain plug when draining of the oil from the engine crankcase is required. Fill with recommeded type oil as listed in Table 5.

21. Air Cleaner – Prevents dirt and other debris from entering the fuel system. Remove wing-nut on top of air filter cannister to gain access to filter element. NEVER run the engine without an air cleaner.

22. Fuel Tank Cap – Remove this cap to add unleaded gasoline to the fuel tank. Replenish with clean unleaded gasoline. Make sure cap is tightened securely. DO NOT over fill.

23. Fuel Gauge – This gauge is located on top of the fuel tank. Read this gauge to determine when fuel is low.

24. FuelTank – Fuel tank capacity is 5 gallons (19 liters).

This HONDA engine is equipped with a low oil shutdown capability. A

NOTE built in sensor will automatically turn off the engine should the oil level fall below a safe operating condition. Make sure the generators is placed

on level ground. Placing the generators on level ground will ensure that the low oil sensor will function properly.

GA-6HE/GA-6HEA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV. #1 (09/30/05) — PAGE 19

Page 18 Page 20
Image 19
Page 18 Page 20
Contents Model GA-6HE/GA-6HEA Page Heres HOW to GET Help Table of Contents When ordering parts Please supply the following information Parts Ordering ProceduresBurn Hazards GA-6HE/GA-6HEA Safety Message Alert SymbolsRespiratory Hazards Rotating Parts Hazards Equipment DamageRead this manual GA-6HE/GA-6HEA Rules for Safe OperationGA-6HE/GA-6HEA Rules for Safe Operation Emergencies DeathOperation and Safety Decals Machine Safety DecalsGA-6HE/GA-6HEA Specifications Generator GA-6HE/GA-6HEA Specifications Engine Specifications EngineDimensions GA-6HE/GA-6HEA DimensionsGA-6HE/GA-6HEA General Information Small Motors Single Phase Load 60 HzGA-6HE/GA-6HEA Load Incandescent LoadsGA-6HE/GA-6HEA Controls and Indicators V Full Power Switch Simplified Diagram Up Position GA-6HE/GA-6HEA Controls and IndicatorsFuelTank Fuel tank capacity is 5 gallons 19 liters GA-6HE/GA-6HEA Controls and IndicatorsGenerator Refueling GA-6HE/GA-6HEA Generator RefuelingMounting GA-6HE/GA-6HEA InstallationOutdoor Installation Indoor InstallationConnecting the Ground GA-6HE/GA-6HEA InstallationMain Circuit Breaker General Inspection Prior to Operation Ground Power ToolsGA-6HE/GA-6HEA PRE-INSPECTION Extension CableFuel Check GA-6HE/GA-6HEA PRE-INSPECTION EngineBefore Starting Engine Oil CheckBefore Starting the Engine GA-6HE/GA-6HEA Initial START-UP EngineGA-6HE/GA-6HEA Initial START-UP/GENERATOR Operation Stopping the Engine Connecting the LoadGenerator Storage GA-6HE/GA-6HEA Preparation for Longterm StorageEngine Maintenance Schedule GA-6HE/GA-6HEA Maintenance EngineSpark Plug Gap Engine Air CleanerGA-6HE Maintenance Battery GA-6HE Generator Wiring Diagram GA-6HE -WIRING Diagram GeneratorGA-6HEA Generator Wiring Diagram GA-6HEA -WIRING Diagram GeneratorEngine Troubleshooting GA-6HE/GA-6HEA -TROUBLESHOOTING EngineWhite Generator Troubleshooting GA-6HE/GA-6HEA -TROUBLESHOOTING GeneratorPage Items Found In the Items Number Column How to read the marks and remarks used in this partsGA-6HE/GA-6HEA Explanation of Code in Remarks Column Items Found In the Remarks ColumnDescription GA-6HE/GA-6HEA Suggested Spare PartsGA-6HE/GA-6HEA Nameplate and Decals Decalwarning GA-6HE/GA-6HEA Nameplate and DecalsName Plate Assy Decal MQ MultiquipGenerator Assy GA-6HE/GA-6HEA Generator AssySET WASHER, Bearing RECTIFIER, D3SB80BEARING, 6304 2RU Nycm SET BOLT, RotorControl BOX ASSY. GA-6HE GA-6HE Control BOX AssyStart SWITCH, ST-403 Full Power SWITCH, ET-330D12Idle Control SWITCH, C1550WA Operation SWITCH, ET-330D12Control BOX ASSY. GA-6HEA GA-6HEA Control BOX AssyGA-6HEA Control BOX Assy Muffler Assy GA-6HE/GA-6HEA Muffler AssyHEX NUT MufflerBolt HEX Head BracketPipe Frame Assy GA-6HE/GA-6HEA Pipe Frame AssyRubber Suspension GA-6HEGA-6HEA BaseBattery Assy GA-6HE/GA-6HEA Battery AssyWing NUT Battery BandBattery Cable Batter BoltAIR Cleaner Assy Honda GX340K1EDE2 Engine AIR Cleaner AssySTAY, AIR Cleaner ELEMENT, AIR CleanerSEPARATOR, AIR Cleaner HOUSING, AIR CleanerCamshaft Assy Honda GX340K1EDE2 Engine Camshaft AssyLIFTER, Valve SPRING, Weight ReturnROD, Push ARM, Valve RockerCarburetor Assy Honda GX340K1EDE2 Engine Carburetor AssyValve SET, Float GASKET, AIR CleanerCLIP, Wire Harness Gasket SETControl Assy Honda GX340K1EDE2 Engine Control AssySPRING, Governor SPRING, Control AdjustingARM, Governor ROD, GovernorCrankcase Cover Assy Honda GX340K1EDE2 Engine Crankcase Cover AssyGASKET, Case Cover WEIGHT, GovernorHOLDER, Governor Weight PIN, Governor WeightCrankshaft Assy Honda GX340K1EDE2 Engine Crankshaft AssyCrankshaft E-TYPE WEIGHT, BalancerCylinder Barrel Assy Honda GX340K1EDE2 Engine Cylinder Barrel AssyBOLT, Drain Plug Switch ASSY., OIL LevelWIRE, Ground SHAFT, Governor ARMCylinder Head Assy Honda GX340K1EDE2 Engine Cylinder Head AssyGASKET, Cylinder Head GUIDE, Valve OS OptionalGUIDE, EX. Valve OS Optional CLIP, Valve GuideFAN Cover Assy Honda GX340K1EDE2 Engine FAN Cover AssyShroud COVER, FAN *NH1* BlackGROMMET, Drain Hole Flywheel Assy Honda GX340K1EDE2 Engine Flywheel AssyFLYWHEEL, Lamp FAN, CoolingNUT, Special 16MM Ignition Coil Assy Honda GX340K1EDE2 Engine Ignition Coil AssyHOLDER, Stop Switch Wire CLAMP, WireGROMMET, Wire WIRE, Stop Switch 470MMPiston Assy Honda GX340K1EDE2 Engine Piston AssyPIN, Piston BOLT, Connecting RODRing SET, Piston STD Piston STDHonda GX340K1EDE2 Engine Recoil Starter Assy SPRING, Starter Return PULLEY, Recoil StarterRATCHET, Starter SPRING, FrictionStarter Motor Assy Honda GX340K1EDE2 Engine Starter Motor AssyBRACKET, Front Contactor AssyArmature BRACKET, CenterLabels Assy Honda GX340K1EDE2 Engine Labels AssyMARK, OIL Caution MARK, AIR CleanerEmblem MARK, ChokeEffective October 1, 2002 Terms and Conditions of Sale Parts Page Your Local Dealer is

GA-6HE, GA-6HEA specifications

The Multiquip GA-6HEA and GA-6HE are innovative generators designed to cater to diverse power needs in various applications, including construction sites, outdoor events, and emergency situations. These models are noted for their robust design and advanced technologies, making them reliable choices for users who demand performance and durability.

One of the main features of the GA-6HEA and GA-6HE is their powerful engine. The generator is equipped with a high-performance engine that provides a consistent and reliable power output. This enables users to run multiple tools or equipment simultaneously without experiencing dips in performance. Moreover, the engines are designed to minimize fuel consumption while maximizing output, ensuring that users can operate for extended periods without the need for constant refueling.

Another standout characteristic of the GA-6HEA and GA-6HE is their versatility. These generators come with multiple outlets, allowing the connection of various devices and tools. Whether for powering job site tools, lighting, or other equipment, these generators deliver the necessary power without hassle. The models are also compact enough to transport easily, making them ideal for mobile applications.

In terms of technology, the generators feature advanced noise reduction technologies that enhance user comfort. They operate quietly, making them suitable for use in residential areas or noise-sensitive environments. This focus on reducing operational noise does not compromise their power output, allowing users to maintain efficiency while adhering to local noise regulations.

Additionally, the GA-6HEA and GA-6HE incorporate user-friendly interfaces and controls, simplifying operation. With easy-start mechanisms and intuitive control panels, users can operate the generators without extensive training or experience. Safety features are also a priority, with built-in protections against overloads and low oil levels, ensuring the longevity of the equipment.

To summarize, the Multiquip GA-6HEA and GA-6HE are exceptional generators equipped with powerful engines, versatile outlets, advanced noise reduction technologies, and user-friendly controls. Their robust design, combined with superior operational characteristics, makes them ideal for a wide range of power generation needs, ensuring reliability and efficiency in any situation. These generators stand out as a go-to choice for professionals seeking dependable power solutions.
Top Page Image Contents