Dixon 966503601, SZ4619 CA manual Adjusting the Mower Deck, Deck Leveling

Page 41

MAINTENANCE

Adjusting the Mower Deck

Deck Leveling

Adjust the deck while the mower is on a level surface. Make sure the tires are inflated to the correct pressure. See Transmission under Technical Data.

If tires are under or over inflated, the deck cannot be properly adjusted.

The deck should be adjusted slightly higher in the rear.

NOTE: To insure accuracy of leveling procedure, mower deck drive belt must be installed prior to leveling deck.

1.Wear heavy gloves. Turn each outer blade tip to align with the deck or in a side-to-side manner.

2.Measure from the floor surface up to the bottom of the blade tip on the discharge side of the mower deck. Retain this measurement.

3.Move to the opposite side, check that measurement is the same. If adjustment is required—with a ¾" or adjustable wrench, turn the lift link adjustment nuts on either side counter clockwise to lower or clockwise to raise. Adjust until both side-to-side measurements are equal.

4.Turn any blade to align with the deck in front- to-rear manner. If the rear blade tip does not measure 1/8" to ½" higher, follow the front adjustment instructions that follow.

5.With a 5/8 or adjustable wrench, turn the nuts on the front suspension linkage. Clockwise raises the front of the mower, counter clockwise will lower the front. Adjust nuts until rear of mower deck is positioned level to 1/8" higher in the rear than the side-to-side measurement.

NOTE: This will place the mower deck in a base measurement position. Additional adjustment may be required to achieve desired cut for the type of grass or conditions being mowed.

8058-030

Lift link adjustment nut

8058-031

Deck front adjustment nuts

41

Page 40 Page 42
Image 41
Page 40 Page 42
Contents Operator Manual Page Table of Contents Page Introduction Manufacturing Number Good ServiceSymbols and decals Manual Performing any General Operation SafetySafety Instructions Never take passengers Slope Operation Personal Safety EquipmentChildren Safe Handling of Gasoline General Maintenance Risk of sparking Spark Arrestor TransportControl Locations ControlsMotion Control Levers Unlocking Transmission Seat Adjustment LeverBypass Linkage Fuel Tank Throttle Control Ignition SwitchChoke Control Cutting Height Adjuster Blade SwitchParking Brake Always use the high position to transportFuel Shut Off Valve FusesSteering TrainingStarting the Engine Before StartingPlace controls in neutral position USE Full Throttle When Mowing To remove cables, reverse order Weak BatteryRunning Mower deck’s anti-scalp rollers should be evenly adjustedOperating On Hills Mowing Tips Stopping the Engine Manual Transport Maintenance Schedule MaintenanceBefore After Year 100 Replacing battery BatteryTire Pressures Safety SystemEZT Belt Installation Faulty adjustment can cause an accidentPump Belt Replacing EZT E-Series Zeroturn Transaxle beltDeck Belt Deck belt installationBelts Anti-scalp Rollers Blade replacementCutting Blades Deck Leveling Adjusting the Mower DeckUse protective glasses when cleaning and washing CleaningCaster Wheels HardwareGeneral LubricationLubrication Schedule Transmission Wheel and Deck ZerksFront Wheel Mount Front Wheel BearingsMaintenance section Trouble ShootingProblem Cause Trouble Shooting Winter Storage ServiceStorage Schematic Torque Specifications Technical DataHex Head Cap Screws Standard HardwareTransmission SZ4619 CA EngineSZ4619 CA Frame DimensionCE requirements Conformity CertificatesUSA requirements Dixon ZTR Residential WarrantyAction Date, mtr reading Stamp, sign Service JournalDelivery Service After 10 hours Daily ServiceAction Date, mtr reading Stamp, signHour Service Service Journal At least once each year Page 115 314827R1 01/15/10

966503601, SZ4619 CA specifications

The Dixon SZ4619 CA,966503601 is a robust vehicle that embodies the perfect blend of performance, technology, and comfort tailored for both personal and commercial use. This model stands out due to its impressive design and innovative features that cater to a wide range of demands.

One of the key features of the Dixon SZ4619 CA is its powerful engine, which provides a remarkable balance of power and fuel efficiency. The engine is designed for optimal performance, enabling swift acceleration and steady handling. The vehicle's engineering ensures that it can handle various terrains, making it suitable for urban environments as well as off-road adventures.

Safety is a paramount concern in the design of the Dixon SZ4619 CA. It comes equipped with advanced safety technologies including anti-lock braking systems (ABS), electronic stability control (ESC), and multiple airbag systems to ensure the utmost protection for both driver and passengers. The vehicle’s sturdy frame and chassis design enhance its crashworthiness, instilling confidence in its operational safety.

In terms of technology, the Dixon SZ4619 CA boasts a modern infotainment system that offers seamless connectivity with smartphones and portable devices. The touch-screen interface is user-friendly, providing access to navigation, audio control, and communication features all in one place. Additionally, the vehicle includes Bluetooth capabilities, allowing hands-free calls and media streaming.

Comfort is another area where the Dixon SZ4619 CA excels. Its spacious interior is designed with high-quality materials and ergonomic seating to ensure a pleasant driving experience. The vehicle features climate control systems that maintain a comfortable cabin temperature regardless of external conditions.

Moreover, the Dixon SZ4619 CA is designed with practicality in mind. It offers ample cargo space and flexible seating arrangements, making it an ideal choice for families, outdoor enthusiasts, or businesses requiring transport flexibility. Fuel efficiency remains a significant attribute, making it a cost-effective option for long-distance travel.

In conclusion, the Dixon SZ4619 CA,966503601 is a well-rounded vehicle that harmoniously integrates performance, safety, technology, and comfort. Whether you are looking for a reliable everyday car or a versatile vehicle for various applications, the Dixon SZ4619 CA promises to deliver an exceptional driving experience. Its combination of powerful features and thoughtful design makes it a formidable option in the competitive automotive landscape.
Top Page Image Contents