Husqvarna 532 43 86-44, 96045002700 owner manual Schematic, SCH12

Page 29

TRACTOR - MODEL NO. YTH2348 (96045002700), PRODUCT NO. 960 45 00-27

SCHEMATIC

SCH12

A

AMMETER (OPTIONAL)

WHITE

S

B M

	BATTERY	SOLENOID
		SOLENOID	STARTER
			STARTER
	RED		M
RED	FUSE		M
RED
		BLACK
		BLACK
	PTO SWITCH		ELECTRIC CLUTCH
	PTO SWITCH	WHITE	BLACK
	(DISENGAGED)
BLACK	H	WHITE
	C

G

A1

GRAY

C F H

B E G

A D

PTO SWITCH

(MATING SIDE)

L A2

BLACK

ORANGE

RED	A	D RED	CLUTCH/BRAKE
	A	D RED	CLUTCH/BRAKE
			(PEDAL UP)
	B	E
		BLACK		REVERSE SWITCH
		BLACK		(NOT IN REVERSE)
				(NOT IN REVERSE)
	BLACK
	BLACK
		2	BLACK
	BLACK	3		SEAT SWITCH
		3	BLACK	(NOT OCCUPIED)
	BLACK	1	BLACK
		1
		6	GRAY
		JUNCTION
		CONNECTOR
	/WHITE			SHORTING
	BLACK			SHORTING
		CHASSIS		CONNECTOR
		CHASSIS
		HARNESS
		IGNITION		SPARK
		UNIT		PLUGS GAP
			(2 PLUGS ON
		(OPTIONAL)	TWIN CYL. ENGINES)
		(OPTIONAL)
	BLUE	HOUR		BLACK
		METER
	FUEL	BLUE		12V	BLACK
	LINE			12V
	LINE
				POWER OUTLET
BLUE				(OPTIONAL)
		CHARGING SYSTEM OUTPUT
	FUEL SHUT-OFF	9 - 1 6 AMP DC @ 3600 RPM
	SOLENOID
	(IF EQUIPPED)	REGULATOR		STATOR
	RED	REGULATOR
	RED
			28 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED)
		BROWN			BLACK
	LIGHT
	SWITCH
			HEADLIGHTS

				3	6	6	3
	IGNITION SWITCH
				2	5	5	2
	POSITION	CIRCUIT	“MAKE”
						4	1
	OFF	M+G+A1		1	4

	RUN/OVERRIDE	B+A1
	RUN	B+A1	L+A2	CHASSIS HARNESS		DASH HARNESS
	START	B + S + A1		CONNECTOR		CONNECTOR
				(MATING SIDE)

WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING.

NON-REMOVABLE CONNECTIONS

REMOVABLE CONNECTIONS

29

Image 29

Contents YTH2348 Safe Operation Practices for Ride-On Mowers Safety RulesGeneral Operation II. Slope OperationGeneral Service ServiceIII. Children IV. TowingTable of Contents Tools Required for Assembly AssemblyUnassembled Parts ToremovetractorfromcartonCheck Deck Levelness Check Tire PressureCheck for Proper Position of ALL Belts Check Brake SystemOperation Reverse Operation System ROS on Position Know Your TractorHOW to USE Your Tractor To Adjust Gauge Wheels See Fig To Adjust Mower Cutting Height See FigSystem Characteristics To Operate MowerUsing the Reverse Operation System Service REMINDER/HOUR MeterReverse Operation System ROS To Transport See FigsCheck Engine OIL Level Before Starting the EngineADD Gasoline To Start Engine See FigPurge Transmission Mowing TipsMaintenance MaintenanceGeneral Recommendations ScheduleTractor BatteryBrake Operation TiresEngine Deck Washout Port See Fig CleaningIN-LINE Fuel Filter See Fig To Remove Mower See Fig Service and AdjustmentsTo Install Mower See Figs Turn Steering Wheel Left and Position Mower See Fig ANTI-SWAY BAR SAttach Mower Side Suspension Arms a to Chassis See Fig Turn nut right Turn nut left To raise mower To Level MowerTo Replace Mower Blade Drive Belt See Fig Mower Drive Belt InstallationTo Replace Motion Drive Belt See Fig Mower Drive Belt RemovalWeak or Dead Fully Charged Battery To Start Engine with a Weak Battery See FigTo Check Brake Front Wheel TOE-IN/CAMBERTo Adjust Throttle Control Cable REMOVAL/REPLACEMENTTo Adjust Choke Control To Adjust CarburetorOther StorageFuel System Engine OILProblem Cause Correction Troubleshooting PointsEngine continues KEY Part Description DecalsWheels and Tires SCH12 SchematicElectrical Socket Asm. Bulb Twistlock 208 Chassis 196 DriveBolt Rdhd Sqnk 3/8-16 x 2-3/4 Gr Engine Spark Arrester KITKEY Part NO. NO. Description Engine Power Rating InformationSteering Assembly Seat Assembly Mower Deck KEY Part NO. NO. Description Mower Lift Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationLimitations and Exclusions HOW to Obtain Service Consumer Wheeled Warranty Chart Front Mounted Deck Riders Engine Transmission 10-20-10 CL