Husqvarna YTH23V42LS owner manual Schematic, SCH12

Page 29

TRACTOR - - MODEL NUMBER YTH23V42LS (96043008801), PRODUCT NO. 960 43 00-88

SCHEMATIC

SCH12

A

AMMETER (OPTIONAL)

WHITE

S

B M

	BATTERY	SOLENOID
		SOLENOID	STARTER
			STARTER
	RED		M
RED	FUSE		M
RED
		BLACK
		BLACK
	PTO SWITCH		ELECTRIC CLUTCH
	PTO SWITCH	WHITE	BLACK
	(DISENGAGED)
BLACK	H	WHITE
BLACK
	C

G

A1

GRAY

C F H

B E G

A D

PTO SWITCH

(MATING SIDE)

L A2

BLACK

ORANGE

RED	A	D RED	CLUTCH/BRAKE
	A	D RED	CLUTCH/BRAKE
			(PEDAL UP)
	B	E
		BLACK		REVERSE SWITCH
		BLACK		(NOT IN REVERSE)
				(NOT IN REVERSE)
	BLACK
	BLACK
		2	BLACK
	BLACK	3		SEAT SWITCH
		3	BLACK	(NOT OCCUPIED)
	BLACK	1	BLACK
		1
		6	GRAY
		JUNCTION
		CONNECTOR
	/WHITE			SHORTING
	BLACK			SHORTING
		CHASSIS		CONNECTOR
		CHASSIS
		HARNESS
		IGNITION		SPARK
		UNIT		PLUGS GAP
			(2 PLUGS ON
		(OPTIONAL)	TWIN CYL. ENGINES)
		(OPTIONAL)
	BLUE	HOUR		BLACK
		METER
	FUEL	BLUE		12V	BLACK
	LINE			12V
	LINE
				POWER OUTLET
BLUE				(OPTIONAL)
		CHARGING SYSTEM OUTPUT
	FUEL SHUT-OFF	9 - 1 6 AMP DC @ 3600 RPM
	SOLENOID
	(IF EQUIPPED)	REGULATOR		STATOR
	RED	REGULATOR
	RED
			28 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED)
		BROWN			BLACK
	LIGHT
	SWITCH
			HEADLIGHTS

				3	6	6	3
	IGNITION SWITCH
				2	5	5	2
	POSITION	CIRCUIT	“MAKE”
						4	1
	OFF	M+G+A1		1	4

	RUN/OVERRIDE	B+A1
	RUN	B+A1	L+A2	CHASSIS HARNESS		DASH HARNESS
	START	B + S + A1		CONNECTOR		CONNECTOR
				(MATING SIDE)

WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING.

NON-REMOVABLE CONNECTIONS

REMOVABLE CONNECTIONS

29

Image 29

Contents YTH23V42LS Safe Operation Practices for Ride-On Mowers Safety RulesGeneral Operation II. Slope OperationIV. Towing ServiceIII. Children Table of Contents Tools Required for Assembly AssemblyUnassembled Parts To Remove Tractor from CartonCheck Deck Levelness Check Tire PressureCheck for Proper Position of ALL Belts Check Brake SystemOperation Mcjk Know Your TractorTo SET Parking BRAKESee Fig HOW to USE Your TractorStopping See Fig To USE Throttle Control D See FigTo Adjust Gauge Wheels See Fig To Adjust Mower Cutting Height See FigTo Move Forward and Backward See Fig To USE Cruise Control J See FigReverse Operation System ROS See Fig To Stop Mower BladesTo Operate on Hills To Transport See FigsCheck Engine OIL Level Before Starting the EngineADD Gasoline Reserve Fuel Valve Operation See FigMowing Tips Service REMINDER/HOUR MeterPurge Transmission Automatic Transmission Warm UPMaintenance MaintenanceGeneral Recommendations ScheduleTractor BatteryBlade Care Blade Removal See FigEngine Deck Washout Port See Fig CleaningIN-LINE Fuel Filter See Fig To Remove Mower See Fig Service and AdjustmentsTo Install Mower See Figs Raise attachment lift lever to highest position To Level Mower Relieve the tension on the belt To Replace Mower Blade Drive BeltTo Check Brake To Replace Motion Drive Belt See Fig Belt InstallationFront Wheel TOE-IN/CAMBER To Remove Wheel for Repairs See FigTo Remove CABLES, Reverse Order To Start Engine with a Weak Battery See FigReplacing Battery See Fig Transmission Other StorageFuel System Engine OILWill not start Loss of powerHard to start Engine will notBattery will not To run when operFires when turn Engine continuesWheels and Tires DecalsSCH12 SchematicTractor - Model Number YTH23V42LS 96043008801, Product no 43 Electrical Chassis Tractor - Model Number YTH23V42LS 96043008801, Product no 43 284 DriveNut U-CHNL 1/4-20 550DP .350 PNL Engine Spark Arrester KITEngine Power Rating Information Steering Assembly 532 41 Wheel, Steering 532 19 532 42 Seat Seat Assembly532 40 34-07 Link Lift Susp Mower Rear Mower LiftMower Deck Tractor - Model Number YTH23V42LS 96043008801, Product no 43 Service Notes Service Notes Service Notes Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe Operation05.12.10 JA