![](/images/new-backgrounds/1104537/10453731x1.webp)
MAINTENANCE
Ariens Dealers will provide any service or adjustments which may be required to keep your unit operating at peak efficiency. Should engine service be required, contact an Ariens dealer or an authorized engine manufacturer's service center.
WARNING: AVOID INJURY. Read and understand the entire Safety section before proceeding.
SERVICE POSITION
WARNING: Before tipping unit up onto housing, remove fuel so no spills will occur and remove battery (if equipped). Ensure unit is secure and will not tip over during maintenance.
Place unit on a flat level surface. Tip unit forward onto front of auger housing for service. Ensure unit is secure and will not tip over. Strap and clamp onto bench if needed.
Service Position
Figure 13 | OS7125 |
|
MAINTENANCE SCHEDULE
The chart below shows the recommended maintenance schedule that should be performed on a regular basis. More frequent service may be required.
MAINTENANCE SCHEDULE
Service Performed | Each Use | Every 5 | Every 25 | Yearly |
|
| hrs. | hrs. |
|
|
|
|
|
|
Check Fasteners | • |
|
|
|
|
|
|
|
|
Check Clutch | • |
|
|
|
Operation |
|
|
|
|
|
|
|
|
|
Check Clutch Spring |
| * | • |
|
Adjustments |
|
|
|
|
|
|
|
|
|
Clean Engine | • |
|
|
|
|
|
|
|
|
Check Engine Oil |
| • |
|
|
|
|
|
|
|
Change Engine Oil |
| ** | • |
|
|
|
| ||
|
|
|
|
|
Check Tire Pressure |
|
| • |
|
|
|
|
|
|
Check Auger |
|
| • | • |
Gearcase |
|
|
|
|
|
|
|
|
|
General Lubrication |
|
| • | • |
|
|
|
|
|
*After first five hours of operation.
**After first two hours of operation.
CHECK FASTENERS
Make sure all hardware is tightened properly.
CHECK CLUTCH OPERATION
Auger / impeller must stop within 3 seconds when attachment clutch/impeller brake lever is released.
Wheels must stop quickly when traction drive clutch lever is released.
If clutches do not engage or disengage properly, adjust or repair before operation (see Attachment Clutch/Brake Adjustment on page 21, Traction Drive Clutch Adjustment on page 23).
CHECK CLUTCH SPRING ADJUSTMENT
Make sure the attachment clutch and traction drive clutch are adjusted to the range specified in Attachment Clutch/Brake Adjustment on page 21.
CLEAN ENGINE
Refer to Engine Manual for detailed instructions.
CHECK ENGINE OIL
The engine crankcase oil should be checked every 5 hours of operation. Oil level MUST be maintained in safe operating range on dipstick at all times or engine damage will result (See Engine Manual).
Park unit on a level surface. Refer to Engine Manual for detailed instructions.
GB - 16