Baja Marine H2X manual Fuel System, Anti-Siphon Valve Inboard/Outboard Engine Only

Section 5 • Fuel System

1.Fuel System

Section 3 • Using Your Boat contains important fueling information. Take time to read all the fuel related information in the owner’s manual.

The H2X standard gasoline fuel system consists of a 80 gallon fuel tank, fuel tank vent, an anti-siphon valve, engine fuel supply line and fuel fill (See Figure 5.1.1).

The fuel tank vent serves as a pressure/vacuum release and safety overflow. The fuel vent is located inside the fuel cap on the port side of the hull. Periodically check the vent to assure that it is not clogged.

!CAUTION

Never start an engine until you are certain that fuel fumes are not present in engine compartment or elsewhere in the boat.

Single Engine

Gas Fuel System

(Fig 5.1.1)

Anti-Siphon Valve (Inboard/Outboard Engine Only)

The fuel pick-up at the fuel tank has an anti-siphon valve to prevent fuel from siphoning out in the event of line failure (See Figure 5.1.1 and 5.1.2). In an emergency situation, remove the anti-siphon valve if the engine is not getting fuel. NOTE: Replace with new anti-siphon valve or fuel shut off valve as soon as possible as anti-siphon protection is required by federal law.

ANTI-SIPHON VALVE
(FIG. 5.1.2)	ANTI-SIPHON VALVE OPEN
		FUEL FLOW
TO ENGINE		FROM FUEL
		TANK

FUEL PUMP SUCTION PULLS OPEN THE SEALING BALL

	ANTI-SIPHON VALVE CLOSED
NO FUEL		FUEL FLOW
		FROM FUEL
PUMP SUCTION
		TANK BLOCKED

SPRING PRESSURE PUSHES THE SEALING BALL CLOSED

fUEl fIll
		fUEl
		Tank
sTaTIC gROUnD
WIRE
fUEl VEnT
#28 ClaMPs
#10 ClaMPs
sTaTIC gROUnD
WIRE	sTaTIC gROUnD
		#10 ClaMPs
	WIRE

fUEl PICk-UP TO EngInE

fUEl sEnDIng UnIT

H2X® 5.1