Outdoor LP Gas Barbecue Grill Model No. RV2301CLB
Troubleshooting
| Problem | Possible Cause | Prevention/Cure |
| |
| ,0 GAS TANK VALVE IS CLOSED | |||
| VALVE TO h/0%.v |
| ||
|
|
| ||
|
|
| ||
| ,0 GAS TANK IS LOW OR EMPTY | 2EPLACE OR REFILL ,0 GAS TANK | ||
|
|
| ||
|
| 4URN ,0 GAS TANK VALVE TO h#,/3%$v | ||
| ,0 GAS LEAK | 7AIT MINUTES FOR GAS TO CLEAR | ||
|
| &OLLOW h#HECKING FOR ,EAKSv IN THE OWNERS MANUAL | ||
| Burner will not light using ignitor |
|
| ||
7IRES OR ELECTRODE COVERED WITH COOKING RESIDUE | #LEAN WIRE ANDOR ELECTRODE WITH RUBBING ALCOHOL | |||
| %LECTRODE AND BURNERS ARE WET | 7IPE DRY WITH CLOTH |
| |
| %LECTRODE CRACKED OR BROKEN SPARKS AT CRACK | Replace electrode |
| |
|
|
| ||
| Wire loose or disconnected | 2ECONNECT WIRE OR REPLACE ELECTRODEWIRE ASSEMBLY | ||
|
|
| ||
| 7IRE IS SHORTING SPARKING BETWEEN IGNITOR AND ELECTRODE | 2EPLACE IGNITOR WIREELECTRODE ASSEMBLY | ||
|
|
|
| |
| Bad ignitor | Replace ignitor |
| |
|
|
| ||
|
| #HECK IF ,0 GAS TANK IS EMPTY | ||
| .O GAS FLOW | ! )F EMPTY REPLACE OR RElLL | ||
| " )F ,0 GAS TANK IS NOT EMPTY REFER TO h3UDDEN DROP IN GAS mOW OR REDUCED | |||
|
| |||
|
| mAME HEIGHTv |
| |
| ,0 GAS TANK IS LOW OR EMPTY | 2EPLACE OR REFILL ,0 GAS TANK | ||
|
| 4URN ,0 GAS TANK VALVE TO h#,/3%$v | ||
| Burner will not light with match | ,0 GAS LEAK | 7AIT MINUTES FOR GAS TO CLEAR | ||
| &OLLOW h#HECKING FOR ,EAKSv IN THE OWNERS MANUAL | |||
| Coupling nut and regulator not fully connected | 4URNING THE COUPLING NUT ABOUT ONEHALF TO THREE QUARTERS ADDITIONAL TURN UNTIL | ||
| SOLID STOP Tighten by hand | |||
|
| |||
| /BSTRUCTION OF GAS FLOW | #LEAR BURNER TUBES |
| |
| #HECK FOR BENT OR KINKED HOSE | |||
|
| |||
| 3PIDER WEBS OR INSECT NEST IN VENTURI | #LEAN VENTURI AND BURNER TUBE | ||
| Burner ports clogged or blocked | Clean burner ports |
| |
| /UT OF GAS | 2EPLACE OR REFILL ,0 GAS TANK | ||
|
|
|
| |
|
| 4URN CONTROL KNOBS TO | /&& | |
|
| 7AIT SECONDS AND LIGHT GRILL | ||
|
| )F mAMES ARE STILL TOO LOW RESET THE EXCESSIVE mOW SAFETY DEVICE | ||
|
| A 4URN CONTROL KNOB | /&& | |
Sudden drop in gas flow or reduced flame height | %XCESS FLOW SAFETY DEVICE MAY HAVE BEEN ACTIVATED | B 4URN ,0 GAS TANK VALVE TO h#,/3%$v | ||
| C $ISCONNECT REGULATOR | |||
|
| D 4URN CONTROL KNOB TO | ()'( | |
|
| E 7AIT MINUTE |
| |
|
| F 4URN CONTROL KNOB TO | /&& | |
|
| G 2ECONNECT REGULATOR AND LEAK CHECK CONNECTIONS | ||
|
| H ,IGHT GRILL PER h,IGHTING )NSTRUCTIONSv | ||
Irregular flame pattern, flame does not run the | Burner ports are clogged or blocked | Clean burner ports |
| |
| full length of burner |
| |||
|
|
| ||
| .EW BURNER MAY HAVE RESIDUAL MANUFACTURING OILS | "URN GRILL FOR MINUTES ON ()'( WITH THE LID CLOSED | ||
| Flame is yellow or orange | 3PIDER WEBS OR INSECT NEST IN VENTURI | #LEAN VENTURI |
| |
&OOD RESIDUE GREASE ETC | Clean burner |
| ||
|
| |||
|
|
| ||
| 0OOR ALIGNMENT OF VALVE TO BURNER VENTURI | !SSURE BURNER VENTURI IS PROPERLY ENGAGED WITH VALVE | ||
|
|
| ||
| (IGH OR GUSTING WINDS | $O NOT USE GRILL IN HIGH WINDS | ||
| Flame blow out |
|
| ||
,OW ON ,0 'AS | 2EPLACE OR REFILL ,0 GAS TANK | |||
|
|
| ||
| %XCESS FLOW VALVE TRIPPED | 2EFER TO h3UDDEN DROP IN GAS FLOW OR REDUCED FLAME HEIGHTv | ||
| Grease buildup | 2EMOVE AND CLEAN ALL GRILL PARTS PER h#LEANING AND #AREv INSTRUCTIONS IN THE | ||
| OWNERS MANUAL |
| ||
|
| |||
|
|
| ||
%XCESS FAT IN MEAT | Trim fat from meat before grilling | |||
| ||||
|
|
| ||
| %XCESSIVE COOKING TEMPERATURE | !DJUST LOWER COOKING TEMPERATURE | ||
|
|
|
| |
|
| 4URN CONTROL KNOBS TO | /&& | |
| Persistent grease fire | Grease trapped by food buildup around burner system | 4URN ,0 GAS TANK VALVE TO h#,/3%$v | ||
,EAVE LID IN CLOSED POSITION AND LET lRE BURN OUT | ||||
|
| !FTER GRILL COOLS REMOVE AND CLEAN ALL PARTS PER h#LEANING AND #AREv | ||
|
| INSTRUCTIONS IN THE OWNERS MANUAL | ||
|
|
| ||
| Flashback (fire in burner tube(s)) | Burner and/or burner tubes are blocked | Clean burners and/or burner tubes | ||
|
|
| ||
| The lid is stainless steel, not painted | Baked on grease buildup has turned to carbon and is flaking off, clean | ||
| THOROUGHLY PER h#LEANING AND #AREv INSTRUCTIONS IN THE OWNERS MANUAL | |||
|
| |||
| Inside of lid is peeling (like paint peeling) |
| s 4HIS CAN BE FROM BAKED ON GREASE BUILDUP THAT HAS TURNED INTO CARBON AND IS | ||
| flaking off |
| ||
| The lid is coated/painted | s #LEAN THOROUGHLY PER h#LEANING AND #AREv INSTRUCTIONS IN THE OWNERS MANUAL | ||
|
| s !FTER CLEANING IF YOU CAN SEE STEEL PLEASE CALL #USTOMER #ARE AT | ||
|
|
| ||