Leak Testing Valves, Hose and Regulator | Char-Broil 463621611

Hold coupling nut and regulator as shown for proper connection to LP cylinder valve.

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools.

NOTE:

If you cannot complete the connection, disconnect regulator and repeat steps 5 and 6. If you are still unable to complete the

connection, do not use this regulator!

DANGER

•Do not insert any tool or foreign object into the valve outlet or safety relief valve. You may damage the valve and cause a leak. Leaking propane may result in explosion, fire, severe personal injury, or death.

WARNING

•Outdoor gas appliance is not intended to be installed in or on a boat.

•Outdoor gas appliance is not intended to be installed in or on an RV.

•Never attempt to attach this grill to the self-contained LP gas system of a camper trailer or motor home.

•Do not use grill until leak-tested.

•If a leak is detected at any time, STOP and call the fire department.

•If you cannot stop a gas leak, immediately close LPcylinder valve and call LP gas supplier or your fire department!

10

Leak Testing Valves, Hose and Regulator

1.Turn all grill control knobs to OFF.

2.Be sure regulator is tightly connected to LP cylinder.

3.Completely open LP cylinder valve by turning hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately. There is a major leak at the connection. Correct before proceeding.

4.Brush soapy solution onto areas circled below, or other similar fittings on your grill.


			NOTE: Your grill
	NOTE: Sideburner		may NOT be
	shelf fascia not		equipped with a
	shown for clarity.		sideburner.

5.If “growing” bubbles appear, there is a leak. Close LP cylinder valve immediately and retighten connections. If leaks

cannot be stopped do not try to repair. Call for replacement

parts.

6.Always close LP cylinder valve after performing leak test by turning hand wheel clockwise.

Image 10

Char-Broil 463621611 manual Leak Testing Valves, Hose and Regulator, Connection, do not use this regulator

Contents

Estimated assembly time 30 minutes Date Purchased Table of Contents This Grill is for Outdoor USE only Installation Safety Precautions California Proposition Lava Rock / Briquettes TemperatureFirst Time Use Pre-Heating Your Grill Indirect Cooking Food SafetyDirect Cooking Rotisserie Cooking Usda Recommended Safe Minimum Internal Temperatures Routine Care Why Clean?General Cleaning Storing Your Grill LP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF SDo not lean over grill while lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting Open lid during lighting Sideburner Match Lighting General Grill CleaningSideburner Ignitor Lighting Burner Flame Check Very Important Burner tubes must reengage valve Cleaning the Burner AssemblyStoring Your Grill Turn gas OFF at control knobs and LP cylinder Limited Warranty All Parts Year from date of purchase Parts List Key Qty Description Parts Diagram Cone side of wheel against leg AssemblyWheels Tank exclusion wire Side braces Firebox assembly Shelves Lid assembly Vaporizer Bar Cooking Grate Swing Away Grease Cup and Grease Cup Clip Tank Retainer Regulator LP Tank Tank Retainer Troubleshooting Emergencies Possible Cause Prevention/Solution Piezo PUSH-BUTTON and Rotary Page Warranty Registration Department Box Columbus, GA