Coleman 5459 instruction manual Danger, Safety, Your For, Series

Screw regulator into stove hand tight. (Fig. 5)

Fig. 5

Remove plastic cap from top of propane bottle and screw propane bottle into regulator hand tight. (Fig. 6)

Fig. 6

Propane cylinder correctly installed. (Fig. 7)

Fig. 7

Never operate stove with propane cylinder in an inverted position. (Fig. 8)

To Light

DANGER

EXPLOSION - FIRE HAZARD

•Propane is heavier than air and can accumulate in low places. If you smell gas, leave the area immediately.

•Always attach or detach propane source outdoors; never while stove is lighted, near flame, pilot lights, other ignition sources or while stove is hot to touch.

•This stove is very hot during use and can ignite flammables too close to the burners. Keep flammables at least 12 inches from the sides and 48 inches from the top of the stove. Keep gasoline and other flammable liquids and vapors well away from stove.

•The stove must not be exposed to flammable vapors or liquids during lighting.

WARNING

BURN HAZARD

•Never leave stove unattended when hot or in use.

•Keep out of reach of children.

Standard Ignition Stoves

Set on sturdy, flat surface. For outdoor use only.

Hold lighted match near burner and open burner valve. (Fig. 9 and 10)

To Turn Off

Close both burner valves firmly. (Fig. 11)

Fig. 11

To Clean

Make sure stove is cool.

Move stove away from flame (including pilot lights) and other ignition sources. Remove propane cylinder from regulator and replace protective cap on cylinder. (Fig. 12)

Fig. 12

Remove regulator from stove. (Fig. 13)

Fig. 13

MAINTENANCE

•Wipe clean with soft cloth and mild dish detergent. Do not use abrasives. (Fig. 14)

Fig. 14

To Store

DANGER

EXPLOSION - FIRE HAZARD

•Never store propane near high heat, open flames, pilot lights, direct sunlight, other ignition sources or where temperatures exceed

120 ºF (49 °C).

•The cylinder must be disconnected when the stove is in storage.

For storage or transport, the regulator may be located below the heat shields. (Fig. 15)

Fig. 15

Things You Should Know

1.It is unsafe and illegal in some places to store or use propane cylinders of greater than 1.14 kg (2.5 lbs.) water capacity (approximately 1 lb. propane) in occupied enclosures.

2.The usual storage areas for camping and picnic equipment are the basement, attic, or garage. To avoid the accumulation of dust, cobwebs, etc., that is common in these storage areas, place your stove in a plastic bag and seal it with a rubber band.

3.For repair service call one of the numbers listed on the front cover for location of your nearest Coleman Service Center. If product must be mailed to Service Center, attach to the product a tag that includes your name, address, daytime telephone number and a description of problem. DO NOT send propane cylinder. Carefully package the product and send either by courier or insured mail with shipping and insurance prepaid to:

For products purchased

in the United States:

The Coleman Company, Inc.

3600 North Hydraulic

Wichita, KS 67219 U.S.A.

1-800-835-3278 • TDD: 1-316-832-8707

For products purchased in Canada: Sunbeam Corporation (Canada) Limited DBA Jarden Consumer Solutions

20B Hereford Street

Brampton, ON L6Y 0M1

1-800-387-6161

4.If not completely satisfied with the performance of this product, please call one of the numbers listed on the cover of this manual.

www.coleman.com

Parts List

Item	Part No.	Description
1	5010001227	Grate & Screw

25010001193 Burner Assembly & Screw

3R430B565T Regulator Assembly

4	R413-149T	Knob & Screw
5	5010001194	Steel Wire Leg
6	5010001192	Lid Assembly (For Stove with lid only)
	1	6

2

5

3

5459 Series

Propane Stoves Réchauds à propane

Instructions for use Notice d’emploi

Note:

Propane tank is not included.

© 2012 The Coleman Company, Inc www.coleman.com

Standard Ignition

Allumage standard

® CERTIFIED ®

ANSI Z21.72-2011/CSA 11.2-2011

Leak Check

WARNING

•Perform leak test outdoors.

•Extinguish all open flames.

•NEVER leak test when smoking.

•Do not use the outdoor stove until connection has been leak tested and does not leak.

Fig. 9

Fig. 10

•Keep stove area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

•Do not obstruct the flow of combustion and ventilation air.

•A good flame should be blue with minimal yellow tip. Some yellow tips on flames are acceptable as long as no carbon or soot deposits appear.

4

Remarque :

La bouteille de propane n’est pas incluse.

IMPORTANT

Read this manual carefully before assembling, using or servicing these stoves. Keep this manual for future reference. If you have questions about assembly, operation, servicing or repair of these stoves, please call Coleman in the United States at 1-800-835-3278 or

TDD: 1-316-832-8707 and in Canada at 1-800-387-6161.

IMPORTANT

Lisez attentivement ce manuel avant d’assembler, d’utiliser ou de réparer le réchaud et gardez-le pour référence ultérieure. Pour toute question en ce qui concerne l’assemblage, le fonctionnement, l’entretien ou la réparation, appelez Coleman au 1-800-835-3278 ou ATS 1-316-832-8707 aux États-Unis et au 1-800-387-6161 au Canada.

English - 5 English - 6 English - 7 English - 8

04)-(ECN20022590 4010016264 4 - English 3 - English

2 - English

1 - English

	(NYSE:JAH) Corporation Jarden de compagnie une		.flame a use
company/ Corporation Jarden a ,.Inc Company, Coleman The
		.Inc Company, Coleman The	Never .leak a indicate Bubbles .water
			soapy using leaks for fittings and
de déposées marques des sont	et	,®Coleman .réservés droits Tous .Inc Company, Coleman The 2012 ©
			connections all check up, set During	•
		.Inc Company, Coleman
			.attaching before damage
The of trademarks registered are	and	,®Coleman .reserved rights All .Inc Company, Coleman The 2012 ©
			for connections propane stove and
		com.coleman.www	cylinder propane Inspect .clean
			fittings and connections all Keep	•
	8707-832-316-1 TDD: 3278-835-800-1
.A.S.U 67219 KS Wichita, • Hydraulic North 3600 • .Inc Company, Coleman The			SAFETY SERVICE

CAUTION

4 .Fig

4) .(Fig .firmly valves burner both Close

3 .Fig

shown as grates Install

2 .Fig

2) .(Fig .hands by lid the Open

1 .Fig

3

2 4

1

.model stove lidded-non the for used be can’t Lid NOTE:

Regulator .4 Grate .3 Screw .2 ) (Optional Lid .1 1) .(Fig .carton from components Remove

	.B339 CAN/CSA
Canada, Transport or Transportation of				.children of reach of out Keep	•
Department .S.U the of cylinders gas-LP
				.use in or hot
for specifications the with accordance
				when unattended stove leave Never	•
in marked and constructed be must
				HAZARD NBUR
stoves with used cylinder(s) gas-LP
The .cylinders propane disposable
.oz 4.16 ®	ColemanNOTE:		Use
.life your endangering avoid
				WARNING
to areas enclosed or unventilated in
use not Do .(CO) monoxide carbon
produces and (oxygen) air consumes				.fires grease
stove This .areas enclosed or
				possible and accumulation grease
unventilated other or vehicle tent,
				avoid to frequently stove Clean	•
camper, house, inside use Never		•
				.Coleman by approved
.only use outdoor For		•
				expressly not part or device any
HAZARD MONOXIDE CARBON
				with use or way any in alter Never
				.only appliance cooking a as Use	•
				.repairs or service for Coleman
				contact and cylinder the remove
DANGER				leak, a still is there If .check leak
				another Perform .tight is it that and
3) .(Fig.				threaded-cross not is connection
	Up Set To			the that Check .leak a indicate
				Bubbles .flame a use Never .water
				soapy using leaks for fittings and
				connections all check up, set During	•
				.attaching before damage
				for connections propane stove and
	565-5430 Regulator:			cylinder propane Inspect .clean
cylinders propane disposable .oz 4.16 Fuel:				fittings and connections all Keep	•
propane regulated Pressure Category:				SAFETY SERVICE
burner per BTU/h 7,000 Input:
				CAUTION
Characteristics
				.use in
	Technical
				not when propane off Turn .58 NFPA
				ANSI/ with or codes and ordinances
				local with compliance in used or
.flame a use Never
				stored be should gas Propane	•
.water soapy using leaks for fittings
				.withdrawal vapor for up set
all check up,-set stove During .parts
				gas propane only Use .leak original
or accessories ®Coleman only Use		•
				the from away feet many kind any
	.adjust to
				of flames open or sparks lighters,
attempt not Do .stove the with
				matches, including sources ignition
came that regulator preset the Use		•
				by ignite can It .possible level lowest
.cylinders disposable refill Never		•
				the to sink will propane leaking
.these about you advise can
				and air than heavier is gas Propane	•
authorities local Your .uses specific for
				.alone smell by detectable always
products producing heat and gases				not is gas leaking so time over fade
fuel of use the govern standards Other				can odorant The .smell egg” “rotten
.use about questions have you if				a as described be can and leaks
authority safety fire local your with				detect help to added normally is
.products our of made be may				odorant An .flammableCheckand odorless,
which use every foresee cannot We				invisible, is gas Propane .gas
.use vehicle recreational				propane by fueled is product This	•
or home for Not
WARNING				WARNING

.life your endangering
avoid to areas enclosed or
unventilated in use not Do .(CO)
monoxide carbon produces
and (oxygen) air consumes
stove This .areas enclosed or
unventilated other or vehicle tent,
camper, house, inside use Never	•
.only use outdoor For	•
immediately! air fresh
product this of operation during
present are symptoms these If .killer
invisible an It’s .it smell can’t you and
it see can’t You .death possibly and
fatigue dizziness, headaches, eyes,
watery symptoms, like-flu produces
poisoning (CO) Monoxide Carbon	•
.stove the of out or into flow air block
not Do .instructions and warnings
all with accordance in maintained
and used if CO of amounts
hazardous-non minute, extremely
produce to designed is product This
.process combustion the during
(CO) monoxide carbon produce
appliances combustion All .appliance
combustion a is stove This	•
HAZARD MONOXIDE CARBON

DANGER
.chamber combustion
the into openings air around
clearances adequate Provide	•
.top the
from inches 48 and sides the from
inches 12 materials: combustible
from clearances Minimum	•
.chemicals unknown
or particles dust thinner,
paint solvents, gasoline, as such
products or combustibles, airborne
or volatile contain may or contain
that spaces in stove the use Never
.ignition of source a be can product
this operation, and lighting During	•
.touch to
hot is stove outdoor while or sources
ignition other lights, pilot flame, near
lighted, is stove outdoor while tank
propane remove or install Never	•
.immediately
area the leave gas, smell you If
.places low in accumulate can
and air than heavier is Propane	•
.°C) (49 ºF 120
exceed temperatures where
or sources ignition other sunlight,
direct lights, pilot flames, open
heat, high near propane store Never	•
HAZARD FIRE - EXPLOSION
DANGER

get

.harm reproductive other or
defects, birth cancer, cause to California
of state the to known chemicals
contain fuel, this of combustion of
productsWARNINGby and
65: PROPOSITION CALIFORNIA
.Inc Company,
Coleman The contact labels, or
manual instruction an as such
information or assistance need you If	•
.stoves these service or use
should instructions the follow and
understand can who persons Only	•
.poisoning monoxide
carbon and/or asphyxiation, burn,
explosion, fire, of hazards from
damage or loss property and injury
bodily serious death, in result
can stoves these with provided
instructions and precautions
the with comply to Failure	•
DANGER

					.equipment fueled
				propane or mechanical any using
				when essential are they as precautions,
				these heed Always .instructions these
	.home or car tent,
				throughout extensively used are below
	camper, a as such			shown symbols following The
					.damage property
	space enclosed
				or injury personal of possibilities the
	an in appliance
			reduce will demanded caution and respect
	this use Never •			the with equipment this Using .servicing
				and storing, using, when necessary are
	.you kill
			precautions These .involved is equipment
	can space enclosed			fueled propane or mechanical any when
				essential are precautions Safety
	an in it Using •			.product the on labeling the
	.odor no
			with conjunction in read be should manual
	has which monoxide		This .product this of users new educate to
	carbon produce		and reference future for manual this Keep
	can appliance This •				.CAUTION”	“
	HAZARD			WARNING”,	“ DANGER”,	“
			symbol alert safety the by accompanied
	MONOXIDE CARBON			information to paid be should attention
			Particular .instructions these throughout
			located also is and page this on presented
				is information safety General .appliance
			propane outdoor this of maintenance and
			operation assembly, the about information
				important contains manual This
				.appliance other any
				or this of vicinity the
				in vapors flammable
				with liquids other
	DANGER			or gasoline use
				or store not Do
	.damage property			SAFETY
	or injury, personal moderate or
	minor in result may avoided, not
fuel, This:				YOUR FOR
	if which, situation hazardous
	tentiallynautiop Ca indicates
	CAUTION
				.supply fuel
	.injury serious			from Disconnect .3
	or death in result could avoided,			.flame open
	not if which, situation hazardous
				any Extinguish .2
	potentiallyarningW	indicates
	WARNING			.appliance light
				to attempt not Do .1
	.injury serious			gas: smell you If
	or death in result will avoided,
				SAFETY
	not if which, situation hazardous
	imminentlyangerDindicates
	DANGER			YOUR FOR